EFF : ALL
25-55-12Page 421
R R Ceiling Panels - AFT Cargo Compartment FR59/FR65 Figure 402B/TASK 25-55-12-991-002-B
R EFF : 401-499, 25-55-12 Page 422 Aug 01/05
CES
TASK 25-55-12-400-002 Installation of the Ceiling Panels in the AFT Cargo Compartment - FR59/FR65
1.
Reason for the Job
__________________
Self Explanatory
2.
Job Set-up Information
______________________
A. Fixtures, Tools, Test and Support Equipment
-------------------------------------------------------------------------------REFERENCE QTY DESIGNATION -------------------------------------------------------------------------------
No specific access platform 2.1 m (6 ft. 11 in.) No specific access platform 3.5 m (11 ft. 6 in.)
B. Consumable Materials
-------------------------------------------------------------------------------REFERENCE DESIGNATION -------------------------------------------------------------------------------
Material No. 11-004 USA MIL-T-81533 1.1.1TRICHLOROETHANE (METHYL CHLOROFORM) (Ref. 20-31-00)
C. Referenced Information
-------------------------------------------------------------------------------REFERENCE DESIGNATION -------------------------------------------------------------------------------
25-68-41-960-001 Replacement of the Decompression Panels 52-30-00-860-001 Open the FWD or AFT Cargo-Compartment Door with the Yellow Electric Pump 52-30-00-860-002 Close the FWD or AFT Cargo-Compartment Door with the Yellow Electric Pump
**ON A/C 001-049, 051-099, 101-149, 201-299, 301-399,
25-55-12-991-002 Fig. 402
EFF : ALL
25-55-12Page 423
Aug 01/05
R
CES -------------------------------------------------------------------------------REFERENCE DESIGNATION -------------------------------------------------------------------------------
**ON A/C 151-199,
25-55-12-991-002-A Fig. 402A R **ON A/C 401-499,
R 25-55-12-991-002-B Fig. 402B **ON A/C ALL
3. Job Set-up
__________
**ON A/C 001-049, 051-099, 101-105,
Subtask 25-55-12-860-051-B
A. Aircraft Maintenance Configuration
(1)
Make sure that the BULK cargo-compartment door is opened
(2)
Make sure that the access platform in position below the opened cargo door.
R **ON A/C 106-149, 151-199, 201-299, 301-399, 401-499,
Subtask 25-55-12-860-051-A
A. Aircraft Maintenance Configuration
(1)
Make sure that the AFT cargo-compartment door is opened and safetied with the actuator safety locks (Ref. TASK 52-30-00-860-001).
(2)
Make sure that the access platform is in position at the opening of the AFT cargo compartment door.
EFF : ALL
25-55-12Page 424
**ON A/C ALL
4. Procedure
_________
**ON A/C 001-049, 051-099, 101-149, 201-299, 301-399,
(Ref. Fig. 402/TASK 25-55-12-991-002)
**ON A/C 151-199,
(Ref. Fig. 402A/TASK 25-55-12-991-002-A) R **ON A/C 401-499,
R (Ref. Fig. 402B/TASK 25-55-12-991-002-B) **ON A/C ALL
Subtask 25-55-12-910-051
A. Preparation for Installation
(1)
Clean the component interface and/or the adjacent area.
(2)
Do an inspection of the component interface and/or the adjacent area.
(3)
If necessary, remove damaged tape (1) from the ceiling panels (2).
(4)
Clean the component interface and/or the adjacent area with CLEANING AGENTS (Material No. 11-004).
(5)
Replace the removed tape (1) on the ceiling panels (2).
(6)
Check the decompression panels as follows:
(a)
Make sure that each decompression panel is in the correct position.
(b)
Make sure that each decompression panel is in the correct condition.
EFF : ALL
25-55-12Page 425
(c) Make sure that the seal of each decompression panel is in the correct condition.
(7) If necessary, replace the applicable decompression panel(s) and/or the seal(s) (Ref. TASK 25-68-41-960-001).
Subtask 25-55-12-420-051
B. Install the Ceiling Panels from FR59 thru FR65
NOTE : The installation of each ceiling panel is the same.
____
(1)
Put the ceiling panels (2) in the correct installation position on the aircraft structure.
(2)
Secure the ceiling panels (2) with the studs (3),(4) and (7).
中國航空網 m.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：A320飛機維護手冊 AMM EQUIPMENT/FURNISHINGS 設備4(34)
