28-42-00
 ALL  ú ú 03 Page 506 ú Jul 12/01
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
737-300/400/500MAINTENANCE MANUAL
 FUEL FEED LOW PRESSURE SWITCH - REMOVAL/INSTALLATION
____________________________________________________
 1.  General_______
 A.  The low pressure switches for the boost pumps for the No. 1 tank are on the front spar of the left wing. The switches for the left boost pump for the center tank are also on the front spar of the left wing. The switches for the boost pumps for the No. 2 tank are on the front spar of the right wing. The switches for the right boost pump for the center tank are also on the front spar of the right wing.
 B.  You cannot replace a low pressure switch for the No. 1 tank or the No. 2 tank with a switch for the center tank. You cannot replace a switch for the center tank with a switch for the No. 1 tank or the No. 2 tank. The electrical connectors on these switches are different. If it is necessary, you can replace a switch for the No. 1 tank with a switch for the No. 2 tank.
 TASK 28-42-11-004-001
 2.  Fuel Feed Low Pressure Switch Removal_____________________________________
 A.  References
 (1)
AMM 27-81-00/201, Leading Edge Flaps

 (2)
AMM 57-30-11/401, Fuel Boost Pump Access Panels

 B.  Access
 (1)  
Location Zone
 303 Left Wing Inboard Leading Edge
 305 Left Fuel Tank
 403 Right Wing Inboard Leading Edge
 405 Right Fuel Tank

 (2)  
Access Panels
 7201 Boost Pump Access Door
 7203 Boost Pump Access Door
 7401 Boost Pump Access Door
 7403 Boost Pump Access Door

 C.  Prepare for the Switch Removal
 EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú

 28-42-11
 ALL  ú ú 02 Page 401 ú Jul 15/91
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
737-300/400/500MAINTENANCE MANUAL
 S 864-024
 WARNING: MAKE SURE THAT PERSONS AND EQUIPMENT ARE CLEAR OF THE LE AND TE
_______ FLAPS AND FLAP DRIVE MECHANISMS BEFORE YOU MOVE THE FLAPS. THE FLAPS CAN CAUSE INJURY TO PERSONS AND DAMAGE TO EQUIPMENT.
 (1)  Extend the leading edge flaps (AMM 27-81-00/201).
 S 494-003
 WARNING: YOU MUST CAREFULLY DO THE STEPS IN THE TASK BELOW TO
_______ INSTALL THE LE FLAP SAFETY LOCKS. THE LE FLAPS CAN MOVE QUICKLY IF YOU DO NOT INSTALL THE SAFETY LOCKS CORRECTLY. THIS CAN CAUSE INJURY TO PERSONS OR DAMAGE TO EQUIPMENT.
 (2)  
Install the flap locks in the leading edge flaps (AMM 27-81-00/201).

 S 864-004

 (3)  
Open these circuit breakers and attach DO-NOT-CLOSE tags:

 (a)  P6 Main Power Distribution Panel
 1) TANK 1 BOOST PUMP FORWARD
 2) TANK 1 BOOST PUMP AFT
 3) TANK 2 BOOST PUMP FORWARD
 4) TANK 2 BOOST PUMP AFT
 5) CENTER TANK BOOST PUMP LEFT
 6) CENTER TANK BOOST PUMP RIGHT
 7) FUEL CONT NO. 1 AFT NO. 2 FWD CTR L
 8) FUEL CONT NO. 1 FWD NO. 2 AFT CTR R

 S 864-005
 (4)  
Make sure the crossfeed valve switch, on the forward overhead panel, is in the CLOSED position.

 S 864-006

 (5)  
Do a check of the quantity of fuel in the applicable tank.

 (a)  If the quantity of fuel in the applicable tank is less than the quantity shown in Table I, it is not necessary to do the procedure: "Close the Removal Valve for the Applicable Boost Pump".
 EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú

 28-42-11
 ALL  ú ú 01 Page 402 ú Jul 12/99
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
737-300/400/500MAINTENANCE MANUAL
 ~.................................................. | | FUEL QUANTITY | | .............................. | FUEL TANK | POUNDS | KILOGRAMS | .................................................... | NO. 1 OR NO. 2 | 3100 | 1400 | | CENTER TANK | 7600 | 3450 | 2.....................…............…...............1
　
中國航空網 m.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：737-300 400 500 AMM 飛機維護手冊 燃油 FUEL 3(164)