May 01/05
R
CES -------------------------------------------------------------------------------REFERENCE DESIGNATION -------------------------------------------------------------------------------
Material No. 19-003 USA AMS 3819 LINT-FREE COTTON CLOTH (Ref. 20-31-00)
C. Referenced Information
-------------------------------------------------------------------------------REFERENCE DESIGNATION -------------------------------------------------------------------------------
52-30-00-860-001 Open the FWD or AFT Cargo-Compartment Door with the Yellow Electric Pump 52-30-00-860-002 Close the FWD or AFT Cargo-Compartment Door with the
Yellow Electric Pump 53-22-14-000-001 Removal of the FWD Cargo-Compartment Floor-Panels 53-22-14-000-002 Removal of the Maintenance Panels at Frame 35.5 53-22-14-400-001 Installation of the FWD Cargo-Compartment
Floor-Panels 53-22-14-400-002 Installation of the Maintenance Panels at Frame 35.5 SRM 511100 P.Block 001 (for corrective action) SRM 512200 P.Block 001 (for corrective action) 53-21-00-991-032 Fig. 620
3. Job Set-up
__________
Subtask 53-21-00-010-092
A. Get Access
WARNING : MAKE SURE THAT THE TRAVEL RANGES OF THE ELEVATORS ARE CLEAR
_______
DURING CARGO COMPARTMENT DOOR OPERATION.
(1)
Put an access platform in position in the zone 130.
(2)
Open the forward cargo compartment door 825 (Ref. TASK 52-30-00-860-001).
(3)
Remove the floor panels of the forward cargo compartment (Ref. TASK 53-22-14-000-001), (Ref. TASK 53-22-14-000-002)
EFF : 301-399, 53-21-00Page A608
May 01/05
R
CES Subtask 53-21-00-110-079
B. Cleaning of the Structure
WARNING : USE SOLVENTS/CLEANING AGENTS, SEALANTS AND OTHER SPECIAL
_______ MATERIALS ONLY WITH A GOOD SUPPLY OF AIR. OBEY THE MANUFACTURERS INSTRUCTIONS. PUT ON PROTECTIVE CLOTHING. DO NOT GET THEM IN YOUR MOUTH. DO NOT SMOKE. DO NOT BREATHE THE GAS. THESE MATERIALS ARE POISONOUS, FLAMMABLE AND SKIN IRRITANT. GET MEDICAL HELP IF YOUR SKIN OR EYES BECOME IRRITATED.
(1) Clean the inspection area with CLEANING AGENTS (Material No. 11-004) and a lint-free cotton cloth MISCELLANEOUS (Material No. 19-003), if necessary.
NOTE : During the inspection, if you find sealant cracked or in bad
____ condition, or with the edges separated from the structure, you must remove and replace sealant.
4. Procedure
_________
Subtask 53-21-00-220-072
A. Inspection
(Ref. Fig. 620/TASK 53-21-00-991-032)
(1)
Do a detailed inspection of the fuselage internal structure between FR24 and FR35.8 from STGR38 to the bottom centerline (left and right sides). This inspection includes the forward face of the pressure bulkhead.
(2)
Make sure that there is no :
(a)
Corrosion damage :
-If you find corrosion damage, refer to the Structural Repair Manual (Ref. SRM 512200 P.Block 001) for types, inspection, removal and corrosion protection.
(b)
Other damage (cracks, scratches, stress, marks, dents, bumps,...):
-If you find this type of damage, refer to the Structural Repair Manual (Ref. SRM 511100 P.Block 001) for damage classification and corrective action.
中國航空網(wǎng) m.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：A320飛機(jī)維護(hù)手冊 AMM FUSELAGE 機(jī)身2(5)
