52-71-00
 ALL  ú ú 07 Page 523 ú Jun 10/95
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
747-400 MAINTENANCE MANUAL
LATCH BELLCRANK

DOOR CLOSED SWITCH
BULK CARGO DOOR SWITCH
E
Cargo Door Warning Switch Adjustment Figure 502 (Sheet 2)
EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú

 52-71-00
 ALL  ú ú 05 Page 524 ú Jun 10/95
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A

747-400
MAINTENANCE MANUAL

SIDE CARGO DOOR
SEE  F  GSEE DOOR WARNING SWITCH 

SWITCH DOOR CLOSED 
DOOR LATCHED SWITCH  SEE  J 
SEE  I 
F 

Cargo Door Warning Switch Adjustment
Figure 502 (Sheet 3)

EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú

 52-71-00
 ALL  ú ú 05 Page 525 ú Jun 10/95
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
747-400
MAINTENANCE MANUAL

MAKE SURE THE ACTUATOR DOES NOT TOUCH THE PLUNGER WHILE YOU SET THIS DIMENSION
Cargo Door Warning Switch AdjustmentFigure 502 (Sheet 4)
EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú

 52-71-00
 ALL  ú ú 04 Page 526 ú Jun 10/95
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
747-400
MAINTENANCE MANUAL

1.55
INCHES
1.49

Cargo Door Warning Switch Adjustment
Figure 502 (Sheet 5)

EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú

 52-71-00
 ALL  ú ú 03 Page 527 ú Jun 15/98
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
747-400 MAINTENANCE MANUAL
 4)  Turn the actuator until the torque increases 15 to 20 pound-inches.
 NOTE: This is where the actuator hits the internal stops.
____
 5) Manually turn the latch actuator twelve turns counterclockwise. 6) Make the switch operate at this point.
 NOTE: Move either the switch or the adjustment bolt
____ to make the switch operate.
 7)  Disconnect the P3 and the P4 connector from the cargo door junction box.
 8)  Make sure there is no continuity between the appropriate connector and ground as follows: a) Pin 12 on the P4 connector or,
 pin 13 on the P3 connector. 9) Connect the P3 and the P4 connector to the cargo door junction box.
 S 715-003
 (5)  
Do a test of the warning system on the forward and aft cargo doors.

 (a)  
Make sure the message for the door shows on EICAS.
 1) DOOR FORWARD CARGO
 2) DOOR AFT CARGO

 (b)  
Close the door.

 (c)  
Make sure the message for the door does not show on EICAS.

 S 825-022
 (6)  
Adjust the warning system on the side cargo door (Fig. 502).

 (a)  
Adjust the door warning switch on the side cargo door.

 NOTE: The door warning switch is on the pressure relief
____ door on the top half of the side cargo door.
 1)  Make sure the head of the bolt is flat against the actuator arm as shown in Detail G, Fig. 502.
 EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú
　
中國航空網 m.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：747-400 AMM 飛機維護手冊 艙門 DOORS 4(76)