(a)
On the Nose Cargo Door Power panel H122:
1) DOOR LIFT
2) PULL UP CAM
3) LATCHES 1-4R
4) LATCHES 1-4L
5) LATCHES 5-8R
6) LATCHES 5-8L
S 715-119
CAUTION: DO NOT CRANK THE LATCH ACTUATOR WITH MORE THAN 8 POUND-FEET
_______ TORQUE. THIS CAN CAUSE DAMAGE TO THE MANUAL DRIVE INPUT.
(3)
Manually crank each of 16 latch actuators to fully latch and unlatch the pins (approximately 150 turns from the fully latch to unlatched position) .
(a)
Make sure the maximum torque is 20 pound-inches during the latch pin extension.
S 865-120
(4)
Remove the DO-NOT-CLOSE tag and close this circuit breaker:
(a)
On the Nose Cargo Door Power panel H122:
1) LATCHES 5-8L
S 715-121
(5)
Hold the control switches in the open position until the latches 5-8 L start to open and then release the switches.
S 865-122
(6)
Open this circuit breaker and attach DO-NOT-CLOSE tag:
(a)
On the Aux/External 2 Power (Center) panel P715:
1) NOSE CARGO DOOR
EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú
52-31-00
ALL ú ú 02 Page 533 ú Oct 18/01
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
747-400 MAINTENANCE MANUAL
S 715-123
(7)
Hold the control switches in the open position and make sure the latches 5-8 L remain in the position.
S 215-124
(8)
Release the control switches and look to see these indications:
(a)
On the door latch annunciator panel:
1) 4 amber NOT LCHD lights 5-8 L come on
2) 4 green LATCHED lights 5-8 L go off.
(b)
On the door control and lights panel:
1) Green LATCHES CLOSED light goes off.
S 865-125
(9)
Remove the DO-NOT-CLOSE tag and close this circuit breaker:
(a)
On the Aux/External 2 Power (Center) panel P715: 1) NOSE CARGO DOOR
S 215-126
(10)
Hold the control switches in the close position to close the latches 5-8 L and look to see these indications:
(a)
On the door latch annunciator panel:
1) 4 green LATCHED lights 5-8 L come on
2) 4 amber NOT LCHD lights 5-8 L go off.
S 865-127
(11)
Release the control switches.
S 865-128
(12)
Open this circuit breaker and attach the DO-NOT-CLOSE tag:
(a)
On the Nose Cargo Door Power panel H122:
1) LATCHES 5-8L
S 715-129
(13)
Do the steps above to do a test on the remaining latches in the following sequence:
(a)
Latches 1-4 L
(b)
Latches 5-8 R
(c)
Latches 1-4 R
K.
Latch Selector Switch Test (Fig. 508)
(1)
Make sure the door is fully closed and latched.
S 865-130
EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú
52-31-00
ALL ú ú 02 Page 534 ú Oct 18/01
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
747-400
MAINTENANCE MANUAL
S 865-131
(2)
Turn the latch selector switch on the latch actuator test panel to the 8L position.
S 215-132
(3)
Push the LATCH CLOSED TEST switch and look to see the green LATCH CLOSED light comes on.
S 215-133
(4)
Do the test above for the 15 remaining latch positions.
S 865-134
(5)
Simultaneously hold the control switches in the open position until all the latches are fully opened.
NOTE: Use a stop watch to monitor the time that it takes to fully
____
open all the latches.
中國航空網 m.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：747-400 AMM 飛機維護手冊 艙門 DOORS 2(19)
