S 862-186

 (2)  
Set the No. 1 AFT FUEL PUMP switch on the P5 forward overhead panel to the OFF position.

 S 812-084

 (3)
Correct the cause of the APU automatic shutdown (AMM 49-00-00/101).

 TASK 49-11-00-862-085
 6. Dry Motor the APU
_________________
 A. General
 (1)  This procedure is used to operate the APU without fuel to the fuel atomizer.
 B. Standard Tools and Equipment
 (1)  
Containers - for fuel, 2 gallon (8 liter) capacity (quantity of 2)

 (2)  
Fuel Drain Hose

 NOTE: The fuel drain hose must connect to the high pressure
____ fuel line for the fuel atomizer and drain into the container.
 C. References
 (1)  AMM 24-22-00/201, Manual Control
 EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú

 49-11-00
 ALL  ú ú 05 Page 219 ú Mar 12/02
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
////////////////////////A / GTCP85-129 SERIES /737-300/400/500/ ENGINES/MAINTENANCE MANUAL ////////////////////////
D. Access
 (1)  
Location Zones
 101 Control Cabin, LH
 205 Electronic Compartment
 703 APU Compartment

 (2)  
Access Panels
 1201 Electronic Equipment Access Door
 3804 APU Cowl Door

 E. Procedure
 S 862-086
 (1)  Set the switch and the circuit breaker:
 (a)  
Set the APU master switch on the P5 forward overhead panel to the OFF position and attach a DO-NOT-OPERATE tag.

 (b)  
Open this circuit breaker and attach a DO-NOT-CLOSE tag: 1) E3-3 Electrical Shelf, APU Control Unit

 S 012-087
 (2)  Open the APU cowl door:
 (a)  
Open the latches for the APU cowl door.

 (b)  
Open the APU cowl door.

 (c)  
Connect the door support rods.

 S 012-088
 CAUTION:_______BE CAREFUL WHEN YOU MOVE THE LOWER SHROUD. DAMAGE TO THE
 SHROUD DRAIN LINES CAN OCCUR.

 (3)  Remove the lower shroud:
 (a)  
Hold the lower shroud and open the shroud latches.

 (b)  
Remove the lower shroud.

 S 942-089
 (4)  
Put the container below the fuel atomizer.

 S 032-091

 (5)  
Disconnect the high pressure fuel line from the fuel atomizer:

 (a)  
Disconnect the high pressure fuel line from the fuel atomizer.

 (b)  
Connect the fuel drain hose to the high pressure fuel line from the fuel atomizer.

 (c)  
Put the end of the fuel drain hose into the container.

 (6)  
Supply external electrical power to the airplane (AMM 24-22-00/201).

 S 912-092
 NOTE: The ac power is necessary to operate the aft boost pump
____
 in the No. 1 fuel tank.

 EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú

 49-11-00
 ALL  ú ú 03 Page 220 ú Mar 12/02
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
S 862-093
 (7)  Set the circuit breaker and these switches:
 (a)  
Remove the DO-NOT-CLOSE tag and close this circuit breaker: 1) E3-3 Electrical Shelf, APU Control Unit

 (b)  
Remove the DO-NOT-OPERATE tag from the APU master switch on the P5 forward overhead panel.

 (c)  
Set the BAT switch on the P5 forward overhead panel to the ON position.

 (d)  
Set the No. 1 AFT FUEL PUMP switch on the P5 forward overhead panel to the ON position.

 NOTE: If you must use the fuel boost pumps in the
____ center tank, you must have a maintenance person or observer in the flight compartment to continuously monitor the LOW PRESSSURE lights. Turn the applicable fuel boost pump to the OFF position if the LOW PRESSURE light for the center tank stays on.
　
中國航空網 m.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：737-300 400 500 AMM 飛機維護手冊 AIRBORNE AUXILIARY POWER 1(69)