(c)
Slowly release the manual reset knob or handle to make sure the poppet is locked in the closed position.
(d)
Continue to release the manual reset knob or handle until the return spring retracts the reset knob or handle into the opening.
NOTE: The outer surface of the knob or handle and the poppet
____ must make a smooth surface with the airplane skin.
S 714-019
(6)
Do this task: Pressure Relief Valve Pressure Check (AMM 28-13-41/601).
(7)
Connect the battery, if you disconnected it.
S 944-024
EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. AIRPLANES WITH THE PRESSURE RELIEF VALVE ú
28-13-41
ú ú 01 Page 408 ú Mar 12/02
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
737-300/400/500MAINTENANCE MANUAL
SURGE TANK FLAME ARRESTER PRESSURE RELIEF VALVE -
_________________________________________________ INSPECTION/CHECK
________________
1. General
_______
A. This procedure has two tasks:
(1)
Close the relief valve manually.
(2)
The pressure check of the relief valve.
B. If you open the relief valve, air will not go through the air vent scoop in the fuel vent system. The air usually goes out of the fuel vent system through the air vent scoop. Too much internal pressure or too much external pressure opens the valve. If the valve is open, you must close it manually.
C. You can do a check of the pressure necessary to open the valve with the valve installed in the airplane. You can do this check with special equipment attached to the external airplane skin.
TASK 28-13-41-406-001
2. Close the Relief Valve Manually
_______________________________
A. Access
(1) Location Zone
304 Right Fuel Vent Surge Tank
404 Left Fuel Vent Surge Tank
B. Procedure
S 216-002
(1) Do a check to see if the relief valve is open.
(a) Find the access panel adjacent to the air vent scoop at the end of the wing (Fig. 601).
NOTE: This panel is not circular.
____
(b)
Find the poppet at the center of the access panel.
(c)
If the valve is open, the poppet is above the bottom surface of the wing.
NOTE: If the valve is open, the manual reset knob and its
____ stem are below the poppet.
S 446-003
(2) Set the poppet to the closed position manually (Fig. 601).
(a)
Hold the manual reset knob and pull it down until the poppet is aligned with the skin.
(b)
Hold the manual reset knob down for 5 seconds.
EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. AIRPLANES WITH THE PRESSURE RELIEF VALVE ú
28-13-41
ú ú 02 Page 601 ú Jul 12/99
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A 737-300/400/500MAINTENANCE MANUAL
(c)
Slowly release the manual reset knob to make sure the poppet is locked in the closed position.
(d)
Continue to release the manual reset knob until the return spring retracts the reset knob into the opening.
NOTE: The outer surface of the knob and the poppet must
____ make a smooth surface with the airplane skin.
TASK 28-13-41-206-004
3. Relief Valve Pressure Check (Fig. 602)
___________________________
A. Special Tools and Equipment
(1) F80166 - Test Fixture, Pressure Relief Valve
(2) F71329 - Leak Tracer ú (3) Pressure monitoring device - 0-5 psig (0-138 inches of water), with ú an accuracy of +/- .018 psig (+/- 0.5 inches of water) ú Use one of these or equivalent: ú (a) DigiMano 2000 ú Available from: ú Netech Corporation ú 60 Bethpage Drive ú Hicksville, NY 11801, USA ú (b) F72951-1 - Water Safety Relief Manometer ú (c) F70208-1 - Water Safety Relief Manometer
中國航空網 m.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：737-300 400 500 AMM 飛機維護手冊 燃油 FUEL 2(14)
