R 1EFF : 001-049, 051-099, 101-105, 151-158, 1 32-31-00Page 568 1201-210, 1May 01/05 1 1 1CES 1
MLG Safety Valve - Location and Detail R Figure 507/TASK 32-31-00-991-024
R 1EFF : 001-049, 051-099, 101-105, 151-158, 1 32-31-00Page 569 1201-210, 1May 01/05 1 1 1CES 1 (3) On the panel 400VU:
-make sure that the landing-gear control-lever 6GA is in the DOWN position
-put a warning notice on the flap/slat control lever to tell persons not to operate the flap/slat system.
Subtask 32-31-00-010-080
B. Get Access
(1)
Open the quick-release door 196BB.
(2)
Open the MLG doors (Ref. TASK 32-12-00-010-001).
(3)
Make sure that a GROUND LOCK SLEEVE (460005835) is installed on each MLG door actuating cylinder.
R (4) Do the flight configuration precautions with electrical power R (Ref. TASK 32-00-00-860-001).
Subtask 32-31-00-865-111
C. Open, safety and tag this(these) circuit breaker(s):
-------------------------------------------------------------------------------PANEL DESIGNATION IDENT. LOCATION -------------------------------------------------------------------------------49VU L/G/LGCIU/SYS1/NORM 1GA C09 121VU HYDRAULIC/BRAKING AND STEERING/SYS2/SPLY 4GG M36 121VU HYDRAULIC/BRAKING AND STEERING/SYS2/CTL 3GG M35 121VU HYDRAULIC/BRAKING AND STEERING/SYS1/CTL 1GG M34 121VU HYDRAULIC/BRAKING AND STEERING/SYS1/IND AND/SPLY 2GG M33 121VU HYDRAULIC/Y HYD/PUMP ENG2/MONG 3700GD Q37 121VU HYDRAULIC/Y HYD/PUMP ENG2/CTL 3701GD Q36 121VU HYDRAULIC/LGCIU/SYS2 2GA Q35 121VU HYDRAULIC/LGCIU/SYS1/GRND SPLY 52GA Q34 121VU HYDRAULIC/G HYD/PUMP ENG1/CTL 1701GK R35 121VU HYDRAULIC/G HYD/PUMP ENG1/MONG 1702GK R34
Subtask 32-31-00-860-105
D. Aircraft Maintenance Configuration
R (1) Put an access platform in position at the RH MLG zone 744.
(2) Disconnect the electrical connector (1) from the safety-valve solenoid.
R 1EFF : 001-049, 051-099, 101-105, 151-158, 1 32-31-00Page 570 1201-210, 1May 01/05 1 1 1CES 1
(3) Put blanking caps on the disconnected electrical connectors.
(4) Remove the GROUND LOCK SLEEVE from the RH MLG door actuating cylinder.
R R (5) If it is necessary to pressurize the Green hydraulic system from the A/C electric pump, do the procedure (Ref. TASK 29-23-00-863-001).
R R (6) If it is necessary to pressurize the Green hydraulic system from an external source, do the steps that follow:
R R NOTE : You can pressurize the Green hydraulic system from the A/C____ electric pump or from an external source as necessary.
R
R (a) Disconnect the isolation coupling of the PTU (Ref. TASK 29-23-00-860-001).
WARNING : MAKE SURE THAT THE CONTROLS AGREE WITH THE POSITION OF_______ THE ITEMS THEY OPERATE BEFORE YOU PRESSURIZE A HYDRAULIC SYSTEM.
R
R R (b) Pressurize the Green hydraulic system (Ref. TASK 29-10-00-863-001).
R R (c) Energize the electrical circuits from the external power (Ref. TASK 24-41-00-861-002).
Subtask 32-31-00-865-113
E. Remove the safety clip(s) and the tag(s) and close this(these) circuit breaker(s): 1GA, 4GG, 3GG, 1GG, 2GG, 3700GD, 3701GD, 2GA, 52GA, 1701GK, 1702GK.
R 1EFF : 001-049, 051-099, 101-105, 151-158, 1 32-31-00Page 571 1201-210, 1May 01/05 1 1 1CES 1
4. Procedure
_________ Subtask 32-31-00-720-073
A. Operational Check of the Landing-Gear Hydraulic Safety-Valve
-------------------------------------------------------------------------------ACTION RESULT -------------------------------------------------------------------------------
1.
Make sure that the travel ranges of the MLG doors are clear.
2.
Try to move the ground door operating-handle to the CLOSE position.
If the MLG door stays open, the safetyvalve is serviceable.
If the MLG door closes, the safety valve is defective.
NOTE : It is possible that the handle
____ will move and the MLG door close because of the remaining pressure. This will only be possible one or two times until the remaining hydraulic pressure is decreased. After this, it must not be possible to close the MLG door.
If it is possible to close the MLG door, the safety valve is defective and must be replaced (Ref. TASK 32-31-17-000-001), (Ref. TASK 32-31-17-400-001).
R 1EFF : 001-049, 051-099, 101-105, 151-158, 1 32-31-00Page 572 1201-210, 1May 01/05 1 1 1CES 1
中國航空網 m.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：A320飛機維護手冊 AMM LANDING GEAR 起落架4(77)
