EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú
29-11-05
ALL ú ú 02 Page 402 ú Feb 10/91
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
747-400
MAINTENANCE MANUAL
5. PULSATION
PUMP SUPPLY PORT
B-B
Hydraulic Pump Fitting Installation
Figure 401 (Sheet 2)
EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú
29-11-05
ALL ú ú 05 Page 403 ú Feb 18/00
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
L08125
A
747-400 MAINTENANCE MANUAL
D. If there is leakage found in the pressure hose from the engine driven pump (EDP), do the following steps to deactivate the EDP:
NOTE: This procedure or a similar one cannot be used for a leaking case
____ drain or supply hose; it can only be used for a leaking pressure hose.
S 864-061
(1)
Depressurize hydraulic system (AMM 29-11-00/201).
S 014-062
(2)
Get access to the pump:
(a)
Open the engine right side cowl panel (AMM 71-11-06/201).
S 034-063
(3)
Remove the pressure hose from the pump.
S 954-064
(4)
Plug the pump output port and the strut hydraulic line.
S 934-066
CAUTION: DO NOT PLACE THE SWITCH IN "SUPPLY OFF." THIS WILL CLOSE THE
_______
SHUTOFF VALVE AND BLOCK FLUID FLOW TO THE PUMP.
(5)
Place the EDP Control Switch in the "Depressurize" position.
(6)
Tag the pump depressurization switch in the Flight Deck.
S 784-067
(7)
Perform a dry motor of engine run with the pump switch in the ON position.
S 934-065
EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú
29-11-05
ALL ú ú 01 Page 404 ú Jun 10/97
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
747-400 MAINTENANCE MANUAL
S 794-068
(8)
Do a Leak Check of the port plug.
E.
Procedure
S 864-002
(1) Supply electrical power (AMM 24-22-00/201).
S 864-003
WARNING: MAKE SURE YOU RELEASE THE PNEUMATIC SYSTEM PRESSURE BEFORE YOU
_______ OPEN THE HYDRAULIC SYSTEM. THE PNEUMATIC SYSTEM PRESSURIZES THE HYDRAULIC RESERVOIR. HYDRAULIC FLUID THAT HAS PRESSURE CAN CAUSE INJURY TO PERSONS.
(2) Release the pressure in the pneumatic system (AMM 36-00-00/201).
S 864-004
WARNING: MAKE SURE YOU RELEASE THE HYDRAULIC SYSTEM PRESSURE BEFORE YOU
_______ OPEN THE HYDRAULIC SYSTEM. HYDRAULIC FLUID THAT HAS PRESSURE CAN CAUSE INJURY TO PERSONS.
(3)
Release the pressure in the hydraulic system (AMM 29-11-00/201).
S 864-005
(4)
Open the applicable EDP DEPRESS circuit breaker:
(a)
P7 Overhead Circuit Breaker Panel
1) 7J2 EDP DEPRESS 1
2) 7H2 EDP DEPRESS 2
3) 7G2 EDP DEPRESS 3
4) 7F2 EDP DEPRESS 4
S 014-039
(5)
Open the thrust reverser half on the right side of the engine (AMM 78-31-00/201).
S 034-042
(6)
Disconnect the EDP (1):
(a)
Disconnect the electrical connector DV349 from the EDP (1).
(b)
Loosen the four nuts (2) which attach the pump to the engine gearbox approximately three turns.
NOTE: If you must loosen the nuts (2) more than three
____ turns hit the shell of the nut to release the self-locking property of the nut.
EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú
中國航空網 m.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：747-400 AMM 飛機維護手冊 液壓 HYDRAULIC 1(103)
