Subtask 36-11-48-865-068
 C. Open, safety and tag this(these) circuit breaker(s): WARNING : OPEN CIRCUIT BREAKERS 1JH, 2JH1, 2JH2, 3JH1 AND 3JH2 (ENGINE 1
_______ AND 2 IGNITION SYSTEMS). THEN OPEN CIRCUIT BREAKERS 2KS1 AND 2KS2 (FADEC A AND EIU 1 AND 2) AND 4KS1 (FADEC B AND EIU 1). IF YOU DO NOT OBEY THIS SEQUENCE, THE ENGINE AUTOMATIC IGNITION- SYSTEM WILL OPERATE. THIS CAN CAUSE INJURY TO MAINTENANCE PERSONNEL.
R 1EFF : 001-049, 051-061, 101-105, 201-203, 1 36-11-48Page 616 1 1 May 01/05 1 1 1CES 1

 Wing Bleed Air Ducting - Access Panel Location
 Figure 603/TASK 36-11-48-991-021

R 1EFF : 001-049, 051-061, 101-105, 201-203, 1 36-11-48Page 617 1 1 May 01/05 1 1 1CES 1

 Wing Bleed Air Ducting, Flexible Connections - Location and Detail
 Figure 604/TASK 36-11-48-991-024

R 1EFF : 001-049, 051-061, 101-105, 201-203, 1 36-11-48Page 618 1 1 May 01/05 1 1 1CES 1

 -------------------------------------------------------------------------------
PANEL DESIGNATION IDENT. LOCATION -------------------------------------------------------------------------------
49VU ENGINE/2/FADEC A/AND EIU 2 49VU ENGINE/1/FADEC A/AND EIU 1 49VU ENGINE/1 AND 2/IGN/SYS A 49VU FLIGHT CONTROLS/SLT/CTL AND MONG/SYS1 121VU ENGINE/IGN/ENG2/SYS B 121VU ENGINE/IGN/ENG1/SYS B 121VU ENGINE/IGN/ENG2/SYS A BAT 121VU ENGINE/IGN/ENG1/SYS A BAT 121VU ENGINE/ENG2/FADEC B 121VU ENGINE/ENG1/FADEC B/AND EIU 1 121VU FLIGHT CONTROLS/SLT/CTL/SYS2  2KS2 2KS1 1JH 5CV 3JH2 3JH1 2JH2 2JH1 4KS2 4KS1 7CV  A05A04A03B06P42P41P40P39Q40R41R21
 Subtask 36-11-48-010-059
 D. Get Access
 (1) Put an access platform, adjustable in position below the wing leading edge panels, zone 510(610).
 (2) Remove the applicable access panels (Ref. TASK 53-35-11-000-001):
 (a) For the LH wing: - remove the access panels 191BT, 521AB, 521BT.
 (b) For the RH wing: - remove the access panels 192BT, 621AB, 621BT.
 (3) Remove and discard the braided wire from the insulation muffs on the flexible connectors (1) thru (5).
 (4) Remove the insulation muffs.
 4. Procedure_________ 
R
 Subtask 36-11-48-790-058 
R R  A. Leak Check of the Bleed Air Flexible Connections (Air supplied by the GAPC) 
R R R  NOTE : APU type APS3200 and Allied Signal 131-9(A) can be used as an____ alternative to the GAPC. Aircraft with APU GTCP 36-300 installed must use the GAPC for this procedure. 

R 1EFF : 001-049, 051-061, 101-105, 201-203, 1 36-11-48Page 619 1 1 May 01/05 1 1 1CES 1

 (1)
 For access to the HP-Ground Connection 7300HM:
 - open the access door 191DB.

 (2)
 Connect a GAPC 0 to 3.5 bar ( 0 to 51 psi) to the HP-Ground
 Connection.

 (3)
 Energize the aircraft electrical circuits
 (Ref. TASK 24-41-00-861-002).

 (4)
 On the AIR COND panel 30VU:

 -put the X BLEED switch to the OPEN position.

 (5)
 On the panel 25VU:

 -
make sure that the ANTI-ICE/WING P/BSW is released (out)

 -
make sure that the ANTI-ICE/WING P/BSW ON light is off.

 (6)
 Start the Ground Air Power Cart (GAPC) and adjust the air pressure slowly until it becomes stable at 40 psi (2.7579 bar).

 (7)
 Use leak detection solution to do a leak check on:

 (a)
 The flexible connectors (1) and (2) on the wing leading edge ducting between rib 7 and rib 8.

 (b)
 The flexible connectors (3), (4) and (5) on the wing to fuselage 'S' duct.

 NOTE : Leakage is permitted when a series of bubbles are
____ continuous on the joint line, and as one bubble breaks another one forms. Leakage is not permitted when air pressure blows detection solution from the joint line and prevents a continuous series of bubbles.
 (8)
 Stop the GAPC.

 (9)
 On the AIR COND panel 30VU:

 -put the X BLEED switch to the AUTO position.
 (10)
 De-energize the aircraft electrical circuits (Ref. TASK 24-41-00-862-002).

 (11)
 Disconnect the GAPC from the HP-Ground Connection.

 (12)
 Replace and/or reseal ducts that leak, (Ref. TASK 36-11-48-000-004) and (Ref. TASK 36-11-48-400-004).

R 1EFF : 001-049, 051-061, 101-105, 201-203, 1 36-11-48Page 620 1 1 May 01/05 1 1 1CES 1

R **ON A/C 001-049, 101-105, 201-203,

R  Subtask 36-11-48-790-057 
R  B. Leak Check of the Bleed Air Flexible Connections (Air supplied by the APU 
R  131-9(A)) 
　
中國航空網 m.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：A320飛機維護手冊 AMM PNEUMATIC 氣源 1(116)