R 28-00-00-200-001 Inspection of the Fuel Tank Bonding 28-12-45-000-001 Removal of the Panel Assembly 550CB(650CB) 28-12-45-400-002 Installation of the Panel Assembly 550CB(650CB) 28-12-46-000-001 Removal of the Overpressure-Protector Outlet 28-12-46-400-001 Installation of the Overpressure-Protector Outlet 28-12-47-000-001 Removal of the NACA Vent Intake 28-12-47-400-001 Installation of the NACA Vent Intake 28-25-00-650-001 Pressure Defuel 28-25-00-650-003 To Drain Remaining Fuel from the Wing Tanks and the
Center Tank 57-17-11-000-001 Removal of the Covers 147AZ (148AZ) 57-17-11-400-001 Installation of the Covers 147AZ (148AZ) 57-27-11-000-001 Removal of the Access Panel (540AB, 540BB, 540CB,
540DB, 540EB, 540FB, 540GB, 640AB, 640BB, 640CB, 640DB, 640EB, 640FB, 640GB)
57-27-11-000-002 Removal of the Access Panel (540HB, 540JB, 540KB, 540LB, 540MB, 540NB, 540PB, 540QB, 540RB, 550AB, 550BB, 550CB, 550DB, 560AB, 640HB, 640JB, 640KB, ....)
57-27-11-400-001 Installation of the Access Panel (540AB, 540BB, 540CB, 540DB, 540EB, 540FB, 540GB, 640AB, 640BB, 640CB, 640DB, 640EB, 640FB, 640GB)
1EFF : ALL 1 28-10-00Page 307 1 1 May 01/04 1 1 1CES 1 -------------------------------------------------------------------------------REFERENCE DESIGNATION -------------------------------------------------------------------------------
57-27-11-400-002 Installation of the Access Panel (540HB, 540JB, 540KB, 540LB, 540MB, 540NB, 540PB, 540QB, 540RB, 550AB, 550BB, 550CB, 550DB, 560AB, 640HB, 640JB, ....)
28-10-00-991-001 Fig. 302
3. Job Set-up
__________ (Ref. Fig. 302/TASK 28-10-00-991-001) Subtask 28-10-00-941-053
A. Safety Precautions
(1)
Put the safety barriers in position.
(2)
Put warning notices around the aircraft to show that the fuel tanks are open.
Subtask 28-10-00-860-050
B. Aircraft Maintenance Configuration
(1)
Defuel the applicable fuel tank (Ref. TASK 28-25-00-650-001).
(2)
Drain the remaining fuel from the applicable fuel tank (Ref. TASK 28-25-00-650-003).
(3)
De-energize the aircraft electrical circuits
(Ref. TASK 24-41-00-862-002).
(4)
Make sure that the aircraft is electrically grounded (Ref. TASK 12-34-24-869-002).
(5)
Make sure that all access platforms and associated equipment are electrically bonded.
(6)
Disconnect the electrical ground power unit.
(7)
Disconnect the aircraft batteries to isolate the aircraft electrical power (Ref. TASK 24-38-51-000-001), but do not remove them.
1EFF : ALL 1 28-10-00Page 308 1 1 May 01/04R 1 1 1CES 1
R Safety Areas And Precautions Figure 302/TASK 28-10-00-991-001
1EFF : 1 1 1CES ALL 1 111 28-10-00 Page 309 Aug 01/99
(8) Drain the fuel that remains from the applicable tank(s) (Ref. TASK 28-25-00-650-003).
Subtask 28-10-00-010-052
C. Get Access
(1) Put the adjustable access platform in position.
(2) Remove the applicable access panel (Ref. TASK 57-27-11-000-001), (Ref. TASK 57-27-11-000-002), (Ref. TASK 57-17-11-000-001), (Ref. TASK 28-12-45-000-001), (Ref. TASK 28-12-46-000-001) or (Ref. TASK 28-12-47-000-001).
Subtask 28-10-00-869-051
D. Preparation of the Tank
(1) Blow clean, filtered air from an air compressor through the tank as follows:
(a) Put the air compressor as far as possible from the aircraft.
(b) Put the end of the compressor supply hose into the tank through an access panel hole.
(c) Start the compressor and make sure that the air flows through the tank.
(d) Continue the air flow for six hours. One person must stay in the area to make sure that the process continues correctly.
Subtask 28-10-00-750-051
R E. Test
R R R R R R R (1) Do a test on the air in the tank with the combustible gas indicator after six hours. If the fuel-gas concentration is more than 10% of the Lower Explosion Limit (LEL), continue to blow air through the tank. Measure the fuel-gas concentration every 15 minutes (in four different areas of the fuel tank) until the fuel-gas concentration is less than 10% of the LEL (or less then the Local Regulatory-Authority limit).
1EFF : ALL 1 28-10-00Page 310 1 1 May 01/04 1 1 1CES 1 1EFF : ALL 1 28-10-00Page 311 1 1 May 01/04 1 1 1CES 1 中國航空網 m.k6050.com 航空翻譯 www.aviation.cn 本文鏈接地址：A320飛機維護手冊 AMM FUEL 燃油1(76)
