曝光臺 注意防騙 網曝天貓店富美金盛家居專營店坑蒙拐騙欺詐消費者

% The outlet from the alternate air valve connects to the turbo-charger. The outlet from the turbo-% charger connects to an intercooler. The outlet from the intercooler connects to the engine inlet % manifold. Refer to Chapter 81 for more data on the turbo-charger and intercooler.
% B. Engine Fuel System
% (1) General
% Fuel from the airplane fuel system goes into the engine fuel filter. The fuel filter is located on % the top right of the engine compartment, adjacent to the firewall.
% The inlet fuel goes through the filter and out to the engine-driven low-pressure fuel pump. The % low-pressure fuel pump supplies fuel to the engine high-pressure pump. The high-pressure % pump supplies fuel to a common rail connected to the injectors. A combined pressure relief and % regulator valve at the end of the common rail controls the fuel pressure. Surplus fuel from the % valve returns to the fuel filter.
Doc # 6.02.01 Page 3
Rev. 4 09 Jan 2003

73-01-00
AMM

% (2) Fuel Filter Heating
% The return fuel from the engine is warm. The fuel filter has a thermostatic bypass.
% If the return fuel is warm but not hot, then the thermostatic bypass guides the return fuel from % the engine into the fuel filter. The return fuel mixes with the cold fuel from the tank and % increases the fuel temperature in the fuel filter. This prevents the fuel filter from becoming % blocked. No fuel returns to the airplane fuel system.
% If the return fuel is hot, then the thermostatic bypass connects the return fuel from the engine % to the return line of the airplane fuel system. Fuel will return to the left tank through the cooling % loop in the right tank (refer to Chapter 28).
% You must examine and replace the filter at the times given in Chapter 05.
Page 4 Doc # 6.02.01 09 Jan 2003 Rev. 4
73-01-00
Engine Fuel and Control
AMM

% Trouble-Shooting % 1. General
% The table below lists the defects you could have with the engine fuel and control system. It only gives % you the data for the air intake, air filter and fuel filter. For more data on trouble-shooting the engine % fuel and control system refer to the engine manufacturer.
% If you have the trouble detailed in the Trouble column read across to the Possible Cause column.
% Then do the repair given in the Repair column. % %

%
%
%

%
%
%

%
%

%
%
%

%
%
%
%

Trouble  Possible Cause  Repair 
Loss of engine power.  Blocked air intake. Dirty/Damaged air filter. Dirty/Damaged fuel filter. Air in fuel distribution system.  Examine the air intake. Remove any obstructions. Refer to Section 71-61. Replace the air filter. Refer to Section 71-61. Replace the fuel filter. Look for contaminated fuel in the airplane fuel system. Refer to Section 28-21. Bleed the fuel distribution system. Refer to Section 28-21. 

%

Doc # 6.02.01 Page 101
Rev. 4 09 Jan 2003

73-01-00
AMM

% Intentionally left blank
73-01-00
Engine Fuel and Control
AMM

% Maintenance Practices % 1. General
% This Section tells you how to remove/install the fuel filter. Only an approved TAE 125 repair shop can % repair the engine fuel system. For more data on the engine fuel and control system refer to the engine % manufacturer.
% Refer to Section 71-61 for maintenance data on the air filter and alternate air valve. Refer to % Chapter 81 for maintenance data on the turbo-charging system.
% % 2. Remove/Install the Engine Fuel Filter and Replace the Element
% A. Remove the Engine Fuel Filter % %
% % % %
% % % % %
%
%
% %

Detail Steps/Work Items  Key Items/References 
WARNING: YOU MUST MAKE SURE THAT THE ENGINE IS SAFE BEFORE YOU DO WORK ON THE ENGINE. IF THE PROPELLER TURNS IT CAN CAUSE INJURY TO PERSONS. 
　
中國航空網 m.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：鉆石40飛機維護手冊 DA 40 SERIES AMM 5(56)