曝光臺 注意防騙 網曝天貓店富美金盛家居專營店坑蒙拐騙欺詐消費者

% WARNING: DO NOT GET FUEL ON YOU. FUEL CAN CAUSE SKIN DISEASE. DO % NOT ALLOW FIRE OR SPARKS NEAR FUEL. FUEL BURNS AND % BURNING FUEL CAN CAUSE INJURY TO PEOPLE AND DAMAGE TO % EQUIPMENT.
% CAUTION: YOU MUST ATTACH CAPS TO HOLES/PIPES WHEN YOU REMOVE % THE ENGINE. IF YOU DO NOT DO THIS, CONTAMINATION CAN % ENTER THE HOLES/PIPES. THIS CAN CAUSE BLOCKAGE TO THE % AIRPLANE SYSTEMS.
% 2. Remove/Install the Engine (without the Engine Mount)
%
%
%
%
%

% A. Equipment %

Item  Quantity  Part Number 
Hoist.  1  Commercial. 
Engine sling.  1  Commercial. 
Engine stand.  1  Commercial. 
Tail trestle.  1  Commercial. 

%

Doc # 6.02.01 Page 201
Rev. 4 09 Jan 2003

71-01-00
AIRCRAFT AMM
%
%
%
%

Oil Filter Housing
%
%

Manifold Temperature % Manifold Pressure Sensor
Connection
%
%
%

Intercooler
%
%
%

Oil Temperature % Sensor %
Oil Filler
%

Coolant Temperature
%

Sensor
%
%

Fuel Return
%
%
%
%
%

Combined
%

Oil Pump
% % % Oil Return from
Turbo-Charger
%
%

Crankshaft 2 Sensor
%
%
%

Oil Pre-Separator
%
%
%

Oil Return from Oil Radiator
Oil Supply to Oil Radiator
Overboard Vent
Oil Separator
Oil Return Line
Starter Motor Alternator Oil Radiator Breather Line
% Figure 2: TAE 125 Diesel Engine Components %
Page 202 Doc # 6.02.01 09 Jan 2003 Rev. 4
71-01-00
DA 40 Series
Power Plant
AMM

%
%
%

%
%
%
%
%
%
%
%
%
%

%
%
%

%

%
%
%

%

%
%
%

%

%
%
%
%

%

% B. Remove the Engine %

Detail Steps/Work Items  Key Items/References 
(1)  Read the engine event log.  Refer to Section 72-01. 
WARNING: MAKE SURE THAT THE ENGINE IS SAFE BEFORE YOU DO ANY WORK ON THE PROPELLER. IF THE ENGINE IS TURNED, THE PROPELLER CAN CAUSE INJURY OR DEATH. 
(2)  Set the emergency fuel valve to OFF. 
(3)  Make sure that the engine is safe: S Set all switches to OFF. S Set the power lever to IDLE. 
(4)  Remove the engine cowlings.  Refer to Section 71-11. 
(5)  Disconnect the airplane main battery.  Refer to Section 24-34. 
(6)  Remove the propeller.  Refer to Section 61-11. 
(7)  Drain the coolant system.  Refer to Section 75-01. 
(8)  Drain the engine oil.  Refer to Section 72-01. 
(9)  Remove the coolant radiator together with the coolant tank.  Refer to Section 75-01. 
(10)  Disconnect the breather line.  At the oil pre-separator. 
(11)  Disconnect the oil hoses between the oil radiator and the engine at the oil filter housing.  Use a suitable container to catch the oil in the tubes. 
(12)  Disconnect the electrical cables from the starter motor. S Disconnect the two control cables at the solenoid. S Disconnect the main supply cable at the solenoid. S Release all clips and ties holding the cables to the engine.  Do not remove clips and ties on the engine mount. 
(13)  Disconnect the electrical cables on the alternator. S Release all clips and ties holding the cables to the engine. 

Doc # 6.02.01 Page 203
Rev. 4 09 Jan 2003

71-01-00
AIRCRAFT
　
中國航空網 m.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：鉆石40飛機維護手冊 DA 40 SERIES AMM 5(20)