Page 4 Doc # 6.02.01 09 Jan 2003 Rev. 4
05-20-00
AMM
Maintenance Checks
3. Engine Ground Test
Do an engine ground test as follows (complete a copy of the Engine Ground Test Record as part of the engine ground test (Refer to Paragraph 7)):
%
% A. Lycoming Version
100 hr items marked X* apply to US registered airplanes only Interval
Inspection Items (Lycoming Version only) 50 100 200 1000 Time Initials
WARNING: DO NOT LET PERSONS GO INTO THE DANGER AREA OF THE PROPELLER. PROPELLERS CAN CAUSE INJURY OR DEATH. WARNING: SET THE PARKING BRAKE TO ON. IF YOU DO NOT DO THIS, THE AIRPLANE CAN MOVE. THIS CAN CAUSE INJURY OR DEATH.
1. Do an operational test of the parking brake. X X X
2. Set the parking brake to ON. X X X X
3. Put the chocks against the airplane main wheels. X X X X
4. Do an engine operational test. For the engine run procedures refer to the DA 40 Airplane Flight Manual. Record the data in the checklist in Section 05-20-00. X X X X
5. Check for carbon monoxide contamination in the cabin. S Switch cabin heat ON. S Use a carbon monoxide tester ('CO-tester'). X X X
6. Do an operational test of the fuel shut-off valve for correct operation. (Refer to Section 28-20). X X X X
7. When the propeller stops rotating, set the ignition switch to the OFF position. Set the ALT/BAT switch to the OFF position. And set the fuel selector to the OFF position. X X X X
Doc # 6.02.01 Page 5
Rev. 4 09 Jan 2003
05-20-00
Maintenance Checks
AMM
%
%
%
%
%
%
%
%
%
%
%
%
%
%
% B. TAE Version %
Interval
Inspection Items (TAE Version only) 50 100 200 1000 Time Initials
WARNING: DO NOT LET PERSONS GO INTO THE DANGER AREA OF THE PROPELLER. PROPELLERS CAN CAUSE INJURY OR DEATH. WARNING: SET THE PARKING BRAKE TO ON. IF YOU DO NOT DO THIS, THE AIRPLANE CAN MOVE. THIS CAN CAUSE INJURY OR DEATH.
1. 2. 3. 4. 5. 6. 7. 8. Do an operational test of the parking brake. Set the parking brake to ON. Put the chocks against the airplane main wheels. Do an engine run. (Refer to the AFM). Check suction. Check engine instruments. Shut engine down. Read FADEC values. (Refer to Section 72-01). X X X X X X X X X X X X X X X X X X X X X X X X X X X X X X
%
Page 6 Doc # 6.02.01 09 Jan 2003 Rev. 4
05-20-00
AMM
Maintenance Checks
4. Maintenance Checklist Zones
Do the applicable checks in each of the zones that follow:
A. Engine Compartment
% Do the checks given in Sub-paragraphs (1) and (3) if the Lycoming engine is installed. Do the % checks given in Sub-paragraphs (2) and (3) if the TAE engine is installed.
% (1) Lycoming Engine
%
100 hr items marked X* apply to US registered airplanes only Interval
Inspection Items (Lycoming engine only) 50 100 200 1000 Time Initials
WARNING: MAKE SURE THE EXHAUST SYSTEM IS COOL BEFORE YOU DO MAINTENANCE ON THE ENGINE. THE EXHAUST SYSTEM CAN BE HOT. THIS CAN CAUSE INJURY TO PERSONS.
1. Remove the top and bottom cowlings. Examine the cowlings. Make sure that the fasteners are serviceable. Look for cracks and areas that have got too hot. X X X X
WARNING: DO NOT GET OIL ON YOU. OIL CAN CAUSE SKIN DISEASE. WARNING: DO NOT GET FUEL ON YOU. FUEL CAN CAUSE SKIN DISEASE. DO NOT ALLOW FIRE NEAR FUEL. FUEL BURNS AND CAN CAUSE INJURY TO PEOPLE AND DAMAGE TO EQUIPMENT.
中國航空網 m.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：鉆石40飛機維護手冊 DA 40 SERIES AMM 1(39)
