(8)  
Make sure the receptacle adapter is not damaged.

 S 653-044
 S 653-046
 EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú

 12-11-05
 ALL  ú ú 01 Page 306 ú Oct 18/01
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
747-400 MAINTENANCE MANUAL
 S 653-047
 (9)  
Install the refuel receptacle cap.

 S 653-048

 (10)
 Repeat the steps for each fuel hose.

 S 413-049

 (11)
 Close and security latch these doors:

 (a)  
Fueling station access door, 521BB and 621BB

 (b)  
Fueling control panel access door, 521CB.

 S 083-050
 (12)
 Disconnect the bonding/grounding cables (AMM 20-41-01/201).

 S 653-051

 (13)
 Do the operator supplied procedures to remove the fuel vehicle.

 S 083-052
 WARNING: DO THE PROCEDURE IN AMM 27-81-00/201 TO REACTIVATE THE EXTENDED
_______ LEADING EDGE FLAPS. THE FLAPS MOVE QUICKLY AND CAN CAUSE INJURY TO PERSONS OR DAMAGE TO EQUIPMENT.
 (14) Do this task for extended leading edge flaps:  Safety Locks Removal and Extended Leading Edge Activation (AMM 27-81-00/201).
 EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú

 12-11-05
 ALL  ú ú 01 Page 307 ú Oct 18/01
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
747-400 MAINTENANCE MANUAL
 ALTERNATE REFUELING PROCEDURES - SERVICING
__________________________________________
 1.  General_______
 A. This procedure contains these tasks:
 (1)  
Refuel Operation - Inoperative Refuel Valve

 (2)  
Refuel Operation - Blank Fuel Quantity Indicator

 (3)  
Refuel Operation - OVERFILL Light Comes On, Refuel Operation Stops

 (4)  
Refuel Operation - Fuel Spill Condition

 (5)  
Refuel Operation - Early Shutoff

 TASK 12-11-06-603-001
 2.  Refuel Operation - Inoperative Refuel Valve___________________________________________
 A. General
 (1)  
This task refuels a fuel tank when a refuel valve does not open electrically.

 (2)  
There is no automatic refuel valve shutoff or overfill protection when a refuel valve is opened manually. If you put too much fuel into the tank, fuel will overfill the tank and enter the surge tank(s). If the fuel flow is not stopped, the surge tank will overfill and an overboard fuel spill will occur.

 (3)  
This task is a manual pressure refuel operation. The fuel quantity processor unit (FQPU) does not control the fuel load distribution during a manual pressure refuel operation. You must monitor the fuel distribution to prevent an out of limits center of gravity (CG) or lateral imbalance condition.

 (4)  
Do a check of the MEL for dispatch with inoperative refuel valves.

 B. References
 (1)  
AMM 12-11-01/301, Fuel Servicing

 (2)  
AMM 12-11-03/301, Manual Pressure Refuel

 (3)  
AMM 28-21-00/201, Refuel

 (4)  
AMM 28-26-00/201, Defuel

 (5)  
FIM 28-21-00/101, Refuel

 C. Access
 (1)  
Location Zones
 500 Left Wing
 600 Right Wing

 (2)  
Access Panels
 521BB Fueling Station Access Door
 521CB Fueling Control Panel Access Door
 621BB Fueling Station Access Door

 D. Prepare the Airplane
 EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú

 12-11-06
 ALL  ú ú 01 Page 301 ú Oct 18/01
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
747-400
MAINTENANCE MANUAL

 S 653-002
　
中國航空網 m.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：747-400 AMM 飛機維護手冊 SERVICING 1(23)