WHEN YOU TOW OR WINCH THE AIRPLANE FROM THE MAIN GEAR Page 4-35 Jul 01/2005
D623N004
 

757
AIRPLANE RECOVERY DOCUMENT
Figure 4-23 LOAD INDICATING DEVICE, TOWING/WINCHING

LOAD CELL CAPACITY IN KIPS  LOAD CELL CAPACITY WITH FIT-TINGS *[1]  APPROXIMATE DIMENSION  RECOMMENDED ALLOY SHACKLE  SHACKLE PIN DIA  APPROX UNIT WEIGHT LB 
A  B  C DIA 
150  A = 150 KIP  17.75  9.0  3.38  80 TON  2.75  60 
150  B = 75 KIP  16.25  9.0  3.38  40 TON  2.25  57 
150  C = 50 KIP  15.50  9.0  3.38  30 TON  2.00  57 
150  D = 100 KIP  17.00  9.0  3.38  61 TON  2.50  60 

*[1] 1. COMMON LOAD CELL USES A VARIETY OF FITTINGS
2. SHEAR LINK REPLACEMENT
4-20-3
WHEN YOU TOW OR WINCH THE AIRPLANE FROM THE MAIN GEAR
Page 4-36 Jul 01/2005
D623N004
 

Figure 4-23 LOAD INDICATING DEVICE, TOWING/WINCHING (Continued)
3. MANUFACTURED BY STRESS-TEK INC, RENTON, WA USA NOTE: 1. REFER TO SECTION 4-20 FOR TOWING LOAD LIMITS ON MAIN AND NOSE GEAR
2.
ORDER BY PART NUMBER 63-010532-XX. THE DASH NUMBER IS KNOWN WHEN YOU FIND THE REQUIRED LOAD CAPABILITY

3.
1.00 INCH = 2.54 CM; 1 LB = 0.4536 KG; 1 TON = 907.2 KG; 1 KIP = 70 KG/SQ CM

4-20-3

WHEN YOU TOW OR WINCH THE AIRPLANE FROM THE MAIN GEAR Page 4-37 Jul 01/2005
D623N004
 
THIS PAGE INTENTIONALLY LEFT BLANK

4-30 WHEN YOU MOVE A DAMAGED AIRPLANE 4-30-1 General
1.  It is important for you to examine the folded landing gear for all possible damage. Do this during the initial airplane inspection. If this is not possible, you must do it after you lift the airplane to a sufficient height.
WARNING: YOU MUST BE VERY CAREFUL WHEN YOU MOVE THE AIRPLANE OR CHANGE ITS ATTITUDE. FUEL LEAKAGE MAY OCCUR AND CAUSE A DANGEROUS CONDITION. YOU MUST MONITOR THE AIRPLANE FOR FUEL LEAKAGE.
2.  If it is possible, move the damaged airplane on its landing gears. If you use the landing gears, it can be necessary to do one of these procedures:
A.  Repair the damaged gear.
B.  Install a replacement gear.
C.  Install some temporary gear supports to hold the weight of the airplane.
3.  If you cannot use the landing gear, you must use a different system to move the airplane. It can be necessary to use one or more of these items:
A.  Trucks (low-bed trailers)
B.  Movable cranes
C.  Transportation dollies
D.  House movement equipment
E.  Commercial transportation equipment
4.  It is possible that you must prepare the ground surface to tow the airplane (see SECTION 2-10 and SECTION 4-10).
　
中國航空網(wǎng) m.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：757 Airplane Recovery Document 飛機(jī)恢復(fù)文件(103)