S 865-002

 (2)  After 5 minutes, operate the lever to open the inner door and drain the chemical precharge.
 (3)  S 865-003Disconnect the service cart drain line and close the waste drain cap.
 (4)  S 865-004Make sure the drain valve handle is open.
 (5)  S 865-005Open this circuit breaker on P414 Power Distribution Panel - Left and attach a DO-NOT-CLOSE tag: (a) 414E19 DRAIN VALVE LAV TANKS U-21
 (6)  S 865-006Close the drain valve handle.
 (7)  S 865-007Connect the flush line from the service cart to the rinse fitting on the service panel.
 (8)  S 865-008Fill the toilet tank with water until the flow automatically stops.
 NOTE:____ Do not use more than 30 gallons of water in this step.
 (9)  S 865-009Disconnect the flush line from the rinse fitting and quickly close the cap for the rinse fitting.
 NOTE:____ You must close the cap quickly to keep most of the water in the rinse line. This water is necessary to do the leak test on the cap.

 S 015-010
 (10)
 Disengage the latches at the bottom of the toilet shroud and remove the shroud.

 S 865-011

 (11)
 Disconnect the rinse line from the rinse line shutoff valve.

 EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. FREIGHTERS ú

 38-32-60
 ú ú 01 Page 509 ú Oct 18/00
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
747-400
MAINTENANCE MANUAL

 S 865-039
 (12) If it is necessary, add water to the rinse line until you can see the water level in the rinse line.
 NOTE: Use a suitable funnel and a water container to add the
____
 necessary water.

 S 865-012
 (13)
 Use a suitable container to add water to the toilet bowl.

 S 865-013

 (14)
 Continue to add water until the level gets to 2 inches below the top of the toilet bowl.

 S 865-014

 (15)
 Make sure the waste drain cap and the inner door (flapper valve) are open.

 S 795-043

 (16)
 After 30 minutes, do a check for leakage from the side and bottom surfaces of the toilet tank.

 NOTE: If there is leakage, stop the test and replace the toilet
____
 tank.

 S 795-016
 (17) Do a check for leakage from the inlet of the rinse line shutoff valve.
 NOTE: If there is leakage, make a note to replace the rinse line
____
 shutoff valve.

 S 795-017
 (18) Do a check for leakage from the hoses and connections on the tank top.
 NOTE: If there is leakage, tighten the connections or make a note
____ to replace the hose(s) as necessary to repair the leak(s).
 EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. FREIGHTERS ú

 38-32-60
 ú ú 01 Page 510 ú Oct 18/00
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
747-400 MAINTENANCE MANUAL
 S 795-018
 (19) Do a check for leakage from the attach points for the toilet bowl, drain valve, motor-pump-assembly, vent fitting and fluid level sensor.
 NOTE: If there is leakage, tighten the fasteners or make a note to
____ replace the gasket(s) as necessary to repair the leak(s).
 S 795-019
 (20)
 If the applicable sidewall and ceiling panels are removed, do a check for leakage from the drain tube and rinse line that connects the service panel to the toilet tank.

 S 795-020

 (21)
 Do a check for leakage at the waste drain tube outlet at the service panel.

 NOTE: If there is leakage, make a note to adjust the ball valve rod
____ assembly or replace the ball valve as necessary to repair the leak.
 S 795-021
 (22) Do a check for leakage from the cap for the rinse fitting on the service panel.
 NOTE: If there is leakage, replace the seal on the cap or replace
____
 the cap as necessary to repair the leak.

 S 865-022
 (23)
 Close the waste drain cap.

 (24)
 Open the drain valve handle.
　
中國航空網 m.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：747-400 AMM 飛機維護手冊 氣動系統 WATER/WASTE(58)