38-32-60
 ú ú 01 Page 202 ú Oct 10/93
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
747-400
MAINTENANCE MANUAL

 (2)  
The seal on the waste drain cap is an O-ring on the inner surface of the cap. The seal on the inner door is an O-ring that is installed around the edge of the inner door.

 (3)  
Do this check at regular intervals to help keep the leakage of waste fluids at the service panel to a minimum.

 B. Standard Tools and Equipment
 (1)  Brush - 1/2-inch wide bristle
 C. Consumable Materials
 (1)  B00260 Cleaner - Emulsion
 D. Access
 (1)  
Location Zone
 124 Area Below Forward Container Compartment, Right

 (2)  
Access Panel
 125A Service Panel, Toilet Drain

 E. Procedure
 S 162-007
 (1)  
If it is necessary, clean the O-rings with water, an emulsion cleaner, and a 1/2-inch wide bristle brush.

 S 212-008

 (2)  
Examine the O-rings for nicks or other defects.

 S 022-009

 (3)  
Replace the defective O-ring(s).

 S 212-010

 (4)  
Examine the metal surfaces on the nipple assembly that touch the O-ring.

 S 422-011

 (5)  
Replace the nipple assembly if there are dents or damage that can cause leakage.

 EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. FREIGHTERS ú

 38-32-60
 ú ú 01 Page 203 ú Oct 10/93
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
747-400 MAINTENANCE MANUAL
 TASK 38-32-60-672-018
 4.  Toilet System Cleaning______________________
 A. General
 (1)  The recommended method to clean the system is to rinse the system for one to two minutes each time the waste tank is drained. A regular rinse of the system will minimize unscheduled maintenance on the waste system.
 B. Consumable Materials
 (1)  
B00490 Chemical Precharge (Deodorant)

 (2)  
B00051 Disinfectant - Deodorizer Lysol Spray
 and Concentrated Deodorizer Lysol

 (3)  
B00639 Honey Bee 76, Mc Gean-Rohco. Downey, CA

 C. Reference
 (1)  AMM 12-17-02/301, Waste Tank Servicing
 D. Access
 (1)  
Location Zones 118 Area Outboard and Above NLG Wheel Wheel (Right) 212 Control Cabin (Right)

 (2)  
Access Panel
 124CR Toilet Service Panel

 E. Procedure
 S 612-025
 (1)  
Drain and then flush the toilet tank (AMM 12-17-02/301).

 S 162-026

 (2)
Do these steps after you have drained the toilet tanks fully:

 NOTE:____Do not add the precharge for the toilet tank. Make sure the flush line from the service cart is connected.
 (a)  
Push the drain valve handle to close the drain valve.

 (b)  
Remove the toilet shroud.

 (c)  
Use a vacuum cleaner to clean loose dirt from the lavatory.

 CAUTION: USE ONLY APPROVED MATERIALS ON THE FLOOR PAN, LIGHT
_______ LENSES, HOSES, AND ELECTRICAL WIRES. OTHER MATERIALS CAN CAUSE DAMAGE TO THESE PARTS.
 (d)  Use an approved disinfectant spray on these parts: 1) The toilet bowl ring 2) The supports for the toilet shroud 3) All cracks and corners of the walls and floor.
 S 112-024
 (3)  Do these steps to clean the toilet tanks:
 EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. FREIGHTERS ú

 38-32-60
 ú ú 01 Page 204 ú Feb 18/02
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A 747-400 MAINTENANCE MANUAL
 CAUTION:_______ FOR HONEY BEE 76, CLEAN UP ANY SPILLED CHEMICAL ON THE AIRPLANE SURFACES. DAMAGE OR DETERIORATION OF THE AIRPLANE STRUCTURE CAN RESULT.
　
中國航空網 m.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：747-400 AMM 飛機維護手冊 氣動系統 WATER/WASTE(53)