NOTE: Direction of manufactured roll shall be perpendicular to centerline of airplane unless otherwise specified.
(b)
Inject sealant into edge retaining devices as required.
(c)
Spread approximately 50 grams per square foot (1.75 ounces) of adhesive to achieve bondline thickness of 0.010 to 0.030 inch over waterseal area. (Installation of mat must start immediately after spreading of adhesive).
(d)
Position mat and sweep or roll out air bubbles and excess adhesive to obtain smooth surface.
(e)
Remove squeeze-out adhesive and clean area with gauze dampened by solvent.
(f)
Check all edges not retained by retaining devices to ensure there are no gaps or voids. Weight all exposed edges during curing period as required.
(g)
Mat should be undisturbed for 12 hours to prevent dimpling from pressure.
501
25-27-211 Page 408 BOEING PROPRIETARY - Copyright . - Unpublished Work - See title page for details. May 15/80
(4)
Install mat (EP45 #X1 film adhesive method)
(a)
Peel protective paper from edge of adhesive sheet previously bonded to mat.
(b)
Position mat along one edge and roll down progressively across floor to prevent air entrapment. Peel off protective paper as required.
(c)
Press mat down firmly with overlapping roller strokes.
(d)
Mat may be walked on immediately.
(5)
Where carpets adjoin mats insert carpets in edge retaining device.
7. Restore Airplane to Normal
A. Install or tighten thresholds as required.
B. Install retainer plate on edge of mat and drain trough.
C. Install escape slide floor brackets adjacent to entry and service doors where required
(Ref 25-61-332).
D. Seal joints at corners of edge retaining devices and around edges of mat as required to ensure water-tight surface.
NOTE: Use only BMS 3-2 general purpose cleaning solvents for final cleaning.
546
May 15/80 BOEING PROPRIETARY - Copyright . - Unpublished Work - See title page for details. 25-27-211 Page 409
PASSENGER CABIN MISCELLANEOUS EQUIPMENT - DESCRIPTION AND OPERATION
1. Thermometer
A. A thermometer, indicating cabin air temperature, is installed at each end of the passenger cabin.
2. Literature Stowage
A. Magazine racks are installed at various locations in the passenger cabin for literature stowage.
B. Literature stowage containers are installed adjacent to passenger seats which face partitions or bulkheads.
3. Vacuum Cleaner Receptacle
A. Two electrical receptacles are provided in the passenger cabin to provide electrical power (115 volts ac) for operation of a vacuum cleaner. One receptacle is installed on the sidewall just forward of each galley service door.
539
Aug 15/72 BOEING PROPRIETARY - Copyright . - Unpublished Work - See title page for details. 25-29-0 Page 1
GALLEYS - DESCRIPTION AND OPERATION
EFFECTIVITY
ALL EXCEPT Airplanes with ATI Interior
1. General
A. The airplane is equipped with three or four galleys, two forward and two aft in the main cabin. The galleys are referred to by number. The forward galleys, No. 1 and 2, are adjacent to the forward service door while the aft galleys, No. 3 and 4, are located adjacent to the aft service door (Fig. 1).
K89540
5C8 Galley Location
Jun 20/85 Figure 1 25-31-0
Page 1
BOEING PROPRIETARY - Copyright . - Unpublished Work - See title page for details.
2. Galley No. 1
A. Galley No. 1, located forward of the forward service door, may be used for the storage of both hot and cold foods and the dispensing of hot coffee and is provided with electrical power and water connections.
3. Galley No. 2
A. Galley No. 2 may be used for the storage of food and galley equipment and is provided with electrical power and water connections. Galley No. 2 stands aft of the forward service door and is connected by a header and curtain track assembly with galley No. 1.
4. Galley No. 3
A. Galley No. 3 is an auxiliary galley and is located forward of the aft service door. Galley No. 3 is a storage unit without electrical or water connections.
5. Galley No. 4
A. Galley No. 4 stands aft of the aft service door. Electrical power and water connections are provided for galley No. 4 which may be used for the storage of both hot and cold foods and the dispensing of hot coffee. This galley is connected by a header and curtain track assembly with the galley No. 3.
中國航空網 m.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：737 AMM 飛機維護手冊 EQUIPMENT/FURNISHINGS(105)
