(2)
Put the warning notice(s) in position to tell persons not to pressurize the Blue hydraulic system:
-in the cockpit on the hydraulic section 40VU of the overhead panel, - on the ground service panel of the Blue hydraulic system.
R 1EFF : 001-049, 051-061, 101-105, 201-203, 1 29-22-00Page 217 1 1 Config-1 May 01/05 1 1 1CES 1
(3)
Make sure that the Blue hydraulic system is depressurized and put it in the maintenance configuration. (Ref. TASK 29-00-00-864-001).
(4)
Depressurize the reservoir of the Blue hydraulic system (Ref. TASK 29-14-00-614-001).
(5)
Extend the Ram Air Turbine (RAT) (Ref. TASK 29-22-00-869-001).
Subtask 29-22-00-865-061
B.
Open, safety and tag this(these) circuit breaker(s):
-------------------------------------------------------------------------------PANEL DESIGNATION IDENT. LOCATION -------------------------------------------------------------------------------106VU CSM/G /EV/MAN/SPLY 6XE B04 121VU HYDRAULIC/RAT/SPLY/EXTN/SOL1 2803GE P33
R **ON A/C 001-049, 051-061, 101-102, 201-202,
121VU HYDRAULIC/RAT/CTL 2801GE P32 R **ON A/C 103-105, 203-203,
121VU HYD/RAT/CTL 2801GE P32 R **ON A/C 001-049, 051-061, 101-105, 201-203,
4. Procedure
_________
Subtask 29-22-00-020-051
A. Removal of the Filter Element CAUTION : MAKE SURE THAT THE PART YOU REMOVE IS THE FILTER PLUG. IF YOU
_______ REMOVE OTHER PARTS YOU CAN CAUSE A MALFUNCTION OF THE RAT.
(1) Remove the filter element (Ref. TASK 29-22-51-000-004).
R 1EFF : 001-049, 051-061, 101-105, 201-203, 1 29-22-00Page 218 1 1 Config-1 May 01/05 1 1 1CES 1 Subtask 29-22-00-210-053
B. Inspection of the Filter Element
(1)
Examine the filter element for metal particles and damage.
(2)
If you find metal particles in the filter element, you must replace the RAT (Ref. TASK 29-22-51-000-001) and (Ref. TASK 29-22-51-400-001).
(3)
If the filter element is damaged, discard it. Subtask 29-22-00-420-051
C.
Install a new or cleaned filter element as required (Ref. TASK 29-22-51-400-004).
NOTE : Make sure that the filter element is clean and not damaged.
____ Subtask 29-22-00-130-050
D. If you retain the filter element to clean it, do the ultrasonic or the chemical cleaning procedure, the pressure test and the bubble test as written below.
Subtask 29-22-00-130-051
E. Ultrasonic Cleaning Procedure of the Filter Element
WARNING : USE SOLVENTS/CLEANING AGENTS, SEALANTS AND OTHER SPECIAL
_______ MATERIALS ONLY WITH A GOOD SUPPLY OF AIR. OBEY THE MANUFACTURERS INSTRUCTIONS. PUT ON PROTECTIVE CLOTHING. DO NOT GET THEM IN YOUR MOUTH. DO NOT SMOKE. DO NOT BREATHE THE GAS. THESE MATERIALS ARE POISONOUS, FLAMMABLE AND SKIN IRRITANT. GET MEDICAL HELP IF YOUR SKIN OR EYES BECOME IRRITATED.
(1)
Put the filter element into a bath of CLEANING AGENTS (Material No. 11-004) to remove the grease.
(2)
Remove the filter element from the cleaning agent and examine it for damage. If it is damaged, discard the filter element.
R 1EFF : 001-049, 051-061, 101-105, 201-203, 1 29-22-00Page 219 1 1 Config-1 May 01/05 1 1 1CES 1
(3)
Clean the filter element ultrasonically or chemically as written below.
For the ultrasonic cleaning procedure:
(4)
Clean the filter element ultrasonically to local regulations. NOTE : Make sure that the open end of the filter element points down
____
when you clean it.
(5)
After the cleaning procedure, continue to the pressure test. Subtask 29-22-00-110-050
F.
Chemical Cleaning of the Filter Element
WARNING : USE SOLVENTS/CLEANING AGENTS, SEALANTS AND OTHER SPECIAL
_______ MATERIALS ONLY WITH A GOOD SUPPLY OF AIR. OBEY THE MANUFACTURERS INSTRUCTIONS. PUT ON PROTECTIVE CLOTHING. DO NOT GET THEM IN YOUR MOUTH. DO NOT SMOKE. DO NOT BREATHE THE GAS. THESE MATERIALS ARE POISONOUS, FLAMMABLE AND SKIN IRRITANT. GET MEDICAL HELP IF YOUR SKIN OR EYES BECOME IRRITATED. 中國航空網 m.k6050.com 航空翻譯 www.aviation.cn 本文鏈接地址：A320飛機維護手冊 AMM HYDRAULIC POWER 液壓5(109)
