(b)
Put blanking caps on the disconnected electrical connectors.
(c)
Remove the nut (29), the bolt (27), the washers (28) and disconnect the bonding strap (4).
(d)
Remove the bolts (22), the washers (21) and (where installed) the washers (24).
Subtask 21-31-51-020-069
B. Preparation for Removal of the Outflow Valve NOTE : This procedure is only applicable for outflow valves P/N
____ 20790-01AA. The outflow valve must be in the open position for this part of the procedure.
(1) Through the open outflow valve:
(a)
Disconnect the electrical connectors (1) 10HL-B, (3) 10HL-A, (23) 10HL-E and (26) 10HL-D.
(b)
Put blanking caps on the disconnected electrical connectors.
(c)
Remove the nut the bolt (27), the washer (28) and disconnect the bonding strap (4).
(d)
Remove the bolts (22), the washers (21) and (where installed) the washers (24).
R 1EFF : 001-049, 051-099, 101-105, 1 21-31-51Page 439 1 1 May 01/05 1 1 1CES 1
Outflow Valve 10HL Figure 402/TASK 21-31-51-991-004- 12 (SHEET 1)
R 1EFF : 001-049, 051-061, 101-105, 1 21-31-51Page 440 1 1 May 01/05 1 1 1CES 1
Outflow Valve 10HL Figure 402/TASK 21-31-51-991-004- 22 (SHEET 2)
R 1EFF : 001-049, 051-061, 101-105, 1 21-31-51Page 441 1 1 May 01/05 1 1 1CES 1
R Outflow Valve 10HL
R Figure 402A/TASK 21-31-51-991-004-A12 (SHEET 1)
R 1EFF : 062-099, 1 21-31-51Page 442 1 1 May 01/05 1 1 1CES 1
R Outflow Valve 10HL
R Figure 402A/TASK 21-31-51-991-004-A22 (SHEET 2)
R 1EFF : 062-099, 1 21-31-51Page 443 1 1 May 01/05 1 1 1CES 1 Subtask 21-31-51-865-066
C. Remove the safety clip(s) and the tag(s) and close this(these) circuit breaker(s):
-3HL.
Subtask 21-31-51-860-050
D. Aircraft Maintenance Configuration
WARNING : MAKE SURE THAT THE TRAVEL RANGES OF THE OUTFLOW VALVES ARE
_______ CLEAR. MOVEMENT OF THE OUTFLOW VALVES CAN CAUSE INJURY TO PERSONS AND/OR DAMAGE TO EQUIPMENT.
WARNING : KEEP AWAY FROM THE MOVING AND ENERGIZED PARTS OF THE OUTFLOW
_______ VALVE WHEN YOU OPERATE OR TEST THE VALVE. THESE CAN CAUSE INJURY TO PERSONS.
(1) Close the outflow valve from the cockpit:
NOTE : For this procedure we recommend that a minimum of two persons
____ are in constant contact with each other through the service interphone system. One person must operate the outflow valve from the cockpit, the other must be at the outflow valve.
(a)
In the zone 312, connect the 600 ohm boomset to the service interphone jack 13RJ.
(b)
In the cockpit: - on the CAPT jack panel, connect the 600 ohm headset to the related connector, - on the overhead panel 50VU make sure that the ON legend on the SVCE INT OVRD pushbutton switch is off, - on the CABIN PRESS panel 25VU make sure that the MODE SEL pushbutton switch is in the MAN position and,
- on the CABIN PRESS panel 25VU set the MAN V/S CTL toggle switch to the DN position to close the outflow valve.
Subtask 21-31-51-865-067
E. Open, safety and tag this(these) circuit breaker(s):
-------------------------------------------------------------------------------PANEL DESIGNATION IDENT. LOCATION -------------------------------------------------------------------------------
122VU AIR COND/CAB PRESS/CTL/MAN 3HL Y23
R 1EFF : 001-049, 051-099, 101-105, 1 21-31-51Page 444 1 1 May 01/05 1 1 1CES 1R **ON A/C 001-049, 051-061, 101-102,
Subtask 21-31-51-020-057
F. Removal of the Outflow Valve
(Ref. Fig. 402/TASK 21-31-51-991-004)
WARNING : SUPPORT THE UNIT/ASSEMBLY OR IT WILL FALL AND BECOME DAMAGED OR
_______ INJURE PERSONNEL. THE UNIT/ASSEMBLY IS HEAVY.
(1)
Remove the screws (7). NOTE : Identify the screws for the installation procedure.
____
(2)
Carefully lift the outflow valve (5) and move it to one side to get access to the electrical connector (2) 10HL-C.
(3)
Disconnect the electrical connector (2) 10HL-C.
(4)
Put blanking caps on the disconnected electrical connectors.
(5)
Lift and carefully remove the outflow valve (5) through the hole in the aircraft skin.
NOTE : The outflow valve weighs approx. 12.5 kg (27.5577 lb).
____
NOTE : Make sure that you do not damage the gasket (6) and that the
____ location pins (8) stay with the outflow valve (5). 中國航空網 m.k6050.com 航空翻譯 www.aviation.cn 本文鏈接地址：A320飛機維護手冊 AMM AIR CONDITIONING 空調 3(35)
