ENGINE MOUNTS
Page 6-5 Apr 11/2002 D623N005
 

6.6 SERVICE INTERFACES
6.6.1 Engine Service Interfaces for Test Cell
Note Figure 6-1 through Figure 6-3 for interface connectors, and Figure 6-4 and Figure 6-5 for locating these connectors.
6-6-1

SERVICE INTERFACES Page 6-6 Apr 11/2002
D623N005

6.6.2 Engine Electrical for Test Cell
The listing of electrical wiring diagrams is shown on Figure 6-6. These diagrams key with the customized wiring drawings provided with the airplane. The drawings enable the test cell designer to design a control system and identify wiring from the control console to the EBU interface.
Electrical harness connections between the EBU and strut are grouped at two principal locations:
.  
Left side, top of fan case

.
Mid spar, strut area for "core" connectors Additional connectors are located at:

.  
Inlet cowl, left side (one connector) for inlet air temperature and probe heater -normally not used if special test inlet is used.

.  
Right side, top of fan case, thrust reverser related connectors.

6-6-2

SERVICE INTERFACES
Page 6-7 Apr 11/2002 D623N005
 

6.6.3 Engine Fuel Interfaces for test Cell
The EBU fuel connection is located on the fan case (right side) connection panel.
Figure 6-1 INTERFACE CONNECTORS (ENGINE)

PNEUMATIC INTERFACE CONNECTORS  VENDOR 
STARTER BACF22AV400F 2320-400 (COUPLING) A2873-400E (SEAL) BLEED DUCT (PRECOOLER) R91AB3-0500FT (FLANGE) 2703-500 (COUPLING) A2873-500 (GASKET) ENGINE MOUNT INTERFACE REAR ENGINE MOUNTS BACB30PN12-30 BOLTS (4) BACW10BP12ACU WASHERS (4) SL4088C12 NUT ASSEMBLIES (2) OR ASCB45-12 NUT ASSEMBLIES (2) 9155-12RBT RETAINERS (2) FRONT ENGINE MOUNTS 310N3024-1 BOLTS (4) 310N3152 WASHERS (4) BACN10HC12 NUTS (4) BACR10V12 RETAINERS (4)  PRESSURE SCIENCE INC PRESSURE SCIENCE INC SHURLOCK AMERACE CORP 

Figure 6-2 FUEL AND HYDRAULIC INTERFACE CONNECTORS

DESCRIPTION  ENGINE SIDE  STRUT SIDE 
HYDRAULIC DRAIN CASE HYDRAULIC PRESSURE HYDRAULIC SUPPLY  MS21907J8 (ELBOW) MS21907J16 (ELBOW) MS21907J20 (ELBOW)  BACU24AB8W (UNION) AS1582-16T (UNION) AS1582-16T (UNION) 

6-6-3
SERVICE INTERFACES
Page 6-8 Apr 11/2002
D623N005
 

Figure 6-2 FUEL AND HYDRAULIC INTERFACE CONNECTORS (Continued) 
DESCRIPTION  ENGINE SIDE  STRUT SIDE 
FUEL THRUST REVERSER EXTEND (LEFT AND RIGHT SIDE) THRUST REVERSER RETRACT (LEFT AND RIGHT SIDE)  MS21907J24 (ELBOW) BACU24AA0608J (UNION) MS21924J6 (ELBOW)  63152-24 (FERRULE) TRANSAMERICA DeLAVAL WIGGINS CONNECTOR DIVISION LOS ANGELES, CA AN924-6J (NUT) AN924-6J (NUT) 
Figure 6-3 ELECTRICAL INTERFACE CONNECTORS

DESCRIPTION  ENGINE SIDE  STRUT SIDE 
RIGHT SIDE  LEFT SIDE 
　
中國航空網 m.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：757 PW2000 Series Engine Ground Handling Document 發(fā)動機地面處理文件(22)