NOTE: It is not necessary to do this task again if you did
____ it during the external oil system inspection.
 (c)  
If you find indications of leakage in Engine No. 2, then do these steps: 1) Do the corrective action shown in the inspection procedures

 or repair the leakage problems that you find. 2) Do the Repair Confirmation at the end of this task.

 (d)  
If you do not find indications of external leakage, then do the Check Engine No. (1, 2) - Smoke/Fumes in the Cabin procedure (AMM 71-00-00/601), and look for indications of oil leakage internal to the engine.

 EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú

 21-00-01
 ALL  ú ú 01 Page 102 ú Nov 15/98
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
 (3)
(4)
A 737-300/400/500MAINTENANCE MANUAL
 (e)  
If you find indications of leakage internal to the engine, then do these steps: 1) Repair the leakage. 2) Do the Repair Confirmation at the end of this task.

 (f)  
If you do not find indications of leakage internal to the

 engine, then continue.Do this check for hydraulic fluid leakage:

 (a)  
Do the Hydraulic Power Inspection Check (AMM 29-00-00/601), and look for leakage.

 (b)  
If you find hydraulic fluid leakage, then do the corrective action indicated in the procedure. 1) Do the Repair Confirmation procedure at the end of this

 task.

 (c)
If you do not find hydraulic fluid leakage, then continue.Do this check for contamination in the air distribution system:

 (a)  
Do the task: Removal of Oil Contamination from the Air Conditioning and Pneumatic Systems (AMM 21-00-01/201). Do this task with Engine No. 2 and the right pack on to see if smoke or odors still appear in the cabin when the left pack is operating.

 (b)  
If smoke or fumes appear, then do a check of the air distribution system for the source of the contamination. Examine: 1) Each of the components of the right pack 2) The main distribution manifold 3) The air distribution ducts where the smoke first appears 4) Replace the component or clean the duct that is the source

 of the smoke. 5) Do the Repair Confirmation at the end of this task.

 (c)  
If smoke or fumes do not appear, then do the full task: Removal of Oil Contamination from the Air Conditioning and Pneumatic Systems (AMM 21-00-01/201), with the two engines, the APU, and the two packs on.

 (d)  
If smoke or fumes appear, do a check of these areas in the air distribution system for the source of the contamination: 1) Each of the components of the pack 2) The main distribution manifold 3) The air distribution ducts where the smoke or fumes first

 appear 4) Replace the component or clean the duct that is the source of the smoke. 5) Do the Repair Confirmation at the end of this task.

 (e)  
If smoke or fumes do not appear, and if the problem does not occur on the subsequent flight, then there was an intermittent fault.

 EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú

 21-00-01
 ALL  ú ú 01 Page 103 ú Mar 15/98
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
737-300/400/500MAINTENANCE MANUAL
 D. Repair Confirmation
 (1)  Check that smoke amd fumes do not appear in the flight deck and passenger cabin when the air conditioning system is operating (AMM 21-00-01/201).
 (a)  
If the oil contamination removal procedure is run until no smoke or fumes are present, and if the problem does not occur on the next flight, you have corrected the fault.

 (b)  
If smoke and fumes remain, go to PROCEDURE 2 and do the steps for contamination in the Engine No. 1, and APU pneumatic systems, and the step for hydraulic leakage.

 3.  PROCEDURE 2: Smoke or Fumes in the Passenger Cabin or Flight Compartment reported during flight. Smoke Stops with Isolation Valve Closed, Left Pack Switch Off.
 A. General:
 (1)  
Make sure the fault report shows the smoke or fumes were stopped with the isolation valve closed, the left pack switch off, and the recirculation fan off. This means that the No. 2 engine, the pneumatic air supply from the No. 2 engine, the right pack, and the related air distribution ducts were not the source of the smoke and fumes.
　
中國航空網 m.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：737-300 400 500 AMM 飛機維護手冊 空調 AIR CONDITIONING 1(14)