49-52-41
ALL ú ú 01 Page 404 ú Nov 15/91
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
SURGE BLEED VALVE - ADJUSTMENT/TEST
___________________________________
1. General
_______
A. This procedure contains a task which does an operational test of the surge bleed valve.
B. During this test, persons must be near the APU while it operates at an rpm more than 95%. Do the test with the APU cowl door closed.
TASK 49-52-41-705-001
2. Operational Test - Surge Bleed Valve
____________________________________
A. References
(1) AMM 49-11-00/201, APU Power Plant
B. Access
(1) Location Zones
102 Flight Compartment, RH
703 Outer Side of APU Compartment
C. Procedure
S 865-002
(1)
Start and operate the APU (AMM 49-11-00/201).
S 865-003
(2)
Make sure these valves are closed:
(a)
The air conditioning valves
(b)
The bleed valves for the main engines
(c)
The thermal anti-icing valves
(d)
The tire seal valves (on the airplanes with the inflatable tire seal)
(e)
The bleed air valve for the APU.
S 715-004
(3) Do the test of the surge bleed valve:
(a) Open this circuit breaker:
1) P6-3 Load Control Center a) LANDING GEAR LIGHTS
EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú
49-52-41
ALL ú ú 02 Page 501 ú Mar 15/92
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
////////////////////////A / GTCP85-129 SERIES /737-300/400/500/ ENGINES/MAINTENANCE MANUAL ////////////////////////
(b) Make sure the surge bleed valve opens.
NOTE: When the valve opens, the flow of air from the
____ exhaust port for the accessory cooling air increases. Also, the EGT and the noise level will increase.
(c)
Turn the switch for the bleed air valve to ON.
(d)
Make sure the noise level and the air flow from the exhaust port for the accessory cooling air decrease.
NOTE: This shows the surge bleed valve is closed.
____
(e) Close this circuit breaker:
1) P6-3 Load Control Center
a) LANDING GEAR LIGHTS
S 865-005
(4) Do the APU usual shutdown (AMM 49-11-00/201).
EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú
49-52-41
ALL ú ú 02 Page 502 ú Mar 15/92
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
3-WAY SOLENOID VALVE - REMOVAL/INSTALLATION
___________________________________________
1. General
_______
A. This procedure contains the removal and the installation tasks for the 3-way solenoid valve. During this procedure, the 3-way solenoid valve is referred to as the solenoid valve.
B. The solenoid valve is on the right aft side of the APU, below the surge bleed valve. You can get access to the valve through the APU cowl door.
TASK 49-52-61-004-001
2. Solenoid Valve Removal (Fig. 401)
______________________
A. References
(1) IPC 49-50-00 Fig. 2
B. Access
(1)
Location Zones
101 Flight Compartment, LH
205 Electronic Compartment
703 APU Compartment
(2)
Access Panels
1201 Electronic Equipment Access Door
3804 APU Cowl Door
C. Procedure
S 864-002
(1) Set the switch and the circuit breaker:
(a)
Set the APU master switch, on the P5 forward overhead panel, to the OFF position and attach a DO-NOT-OPERATE tag.
(b)
Open this circuit breaker and attach a DO-NOT-CLOSE tag: 1) E3-3 Electrical Shelf, APU Control Unit
S 014-003
(2) Open the APU cowl door:
(a) Open the latches for the APU cowl door.
中國航空網 m.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：737-300 400 500 AMM 飛機維護手冊 AIRBORNE AUXILIARY POWER 2(93)
