EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú

 49-31-00
 ALL  ú ú 01 Page 211 ú Jul 15/92
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
APU FUEL SYSTEM - ADJUSTMENT/TEST
_________________________________
 1.  General
_______
 A.  This procedure has two checks for the fuel supply system for the APU. These are the two checks.
 (1)  
The Flow Check of the APU Fuel Supply System

 (2)  
The pressure check of the APU Fuel Supply System.

 B.  The flow check of the APU fuel supply system makes sure the correct quantity of fuel is supplied to the APU. The pressure check of the APU fuel supply system makes sure the correct fuel pressure is supplied to the APU.
 TASK 49-31-00-705-001
 2.  APU Fuel Supply System Flow Check
_________________________________
 A.  Standard Tools and Equipment
 (1)  
Container - 5 gallon (20 liter) capacity, for fuel

 (2)  
Hose - for fuel, sufficient length to transmit fuel from the fuel line to the container

 (3)  
Fitting - to connect the fuel hose to the fuel line for the low-pressure fuel filter

 B.  References
 (1)  
AMM 24-22-00/201, Manual Control

 (2)  
AMM 28-22-00/101, Engine Fuel Distribution System

 C.  Access
 (1)  
Location Zones
 101 Control Cabin (Left)
 205 Electronic Compartment
 703 APU Compartment

 (2)  
Access Panels
 1201 Electronic Equipment Access Door
 3804 APU Cowl Door

 D.  Procedure
 S 865-035
 (1)  Set the switch and these circuit breakers:
 (a)  
Set the APU master switch, on the P5 forward overhead panel, to the OFF position and attach a DO-NOT-OPERATE tag.

 (b)  
Make sure the No. 1 AFT FUEL PUMP switch is in the OFF position.

 NOTE: The No. 1 AFT FUEL PUMP switch is on the P5 forward
____
 overhead panel.

 (c)  Open this circuit breaker and attach a DO-NOT-CLOSE tag: 1) E3-3 Electrical Shelf, APU Control Unit
 EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú

 49-31-00
 ALL  ú ú 02 Page 501 ú Jul 15/98
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
////////////////////////A / GTCP85-129 SERIES /737-300/400/500/ ENGINES/MAINTENANCE MANUAL ////////////////////////
S 015-003
 (2)  Open the APU cowl door:
 (a)  
Open the latches for the APU cowl door.

 (b)  
Open the APU cowl door.

 (c)  
Connect the door support rods.

 S 015-004
 CAUTION:_______BE CAREFUL WHEN YOU MOVE THE LOWER SHROUD. DAMAGE TO THE SHROUD DRAIN LINES CAN OCCUR.
 (3)  Remove the lower shroud:
 (a)  
Hold the lower shroud and open the shroud latches.

 (b)  
Remove the lower shroud.

 S 435-005
 (4)  Install the fuel hose:
 (a)  
Disconnect the fuel line from the low-pressure fuel filter.

 (b)  
Use the fitting to connect the fuel hose to the fuel line for the low-pressure fuel filter.

 (c)  
Put the other end of the fuel hose in the container.

 S 915-006
 (5)  Supply external electrical power to the airplane (AMM 24-22-00/201).
 NOTE: The ac power is necessary to operate the aft boost pump
____
 in the No. 1 fuel tank.

 S 865-007
 (6)  Set the No. 1 AFT FUEL PUMP switch to the ON position.
 NOTE: The No. 1 AFT FUEL PUMP switch is on the P5 forward
____
 overhead panel.

 NOTE: If you must use the fuel boost pumps in the center tank,
____ you must have a maintenance person or observer in the flight compartment to continuously monitor the LOW PRESSSURE lights. Turn the applicable fuel boost pump to the OFF position if the LOW PRESSURE light for the center tank stays on.
 S 865-017
　
中國航空網(wǎng) m.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：737-300 400 500 AMM 飛機(jī)維護(hù)手冊 AIRBORNE AUXILIARY POWER 2(14)