(2)
AMM 36-00-00/201, Pneumatic System
C. Access
(1)
Location Zone 315/316 Area Aft of Stabilizer Box Compartment
(2)
Access Panel
315AL Door - Access
D. Procedure
S 864-186
(1)
Release the pressure in the pneumatic system (AMM 36-00-00/201).
S 014-187
(2)
Open the 315AL access door in the area aft of the stabilizer box compartment.
S 214-188
(3)
Get access to the APU pneumatic duct restraint.
S 034-171
(4)
Remove the nut from the T-bolt.
S 034-172
(5)
Remove both bolts (along with washers, nuts, and radius fillers) between the duct restraint strap and the two restraint cables.
S 034-173
(6)
Remove the duct restraint clamp.
S 034-174
(7)
Remove the duct restraint strap.
TASK 36-11-01-004-194
15. Install the APU Duct Restraint (Fig. 406)
______________________________
A. General
(1) This procedure contains one task. The procedure gives instructions to attach the APU duct restraint cable to the pneumatic duct.
B. References
(1)
AMM 06-09-05/201, Body Section 48 Access Doors and Panels
(2)
AMM 36-00-00/201, Pneumatic System
C. Access
(1)
Location Zone 315/316 Area Aft of Stabilizer Box Compartment
(2)
Access Panel
315AL Door - Access
D. Procedure
S 864-189
(1) Release the pressure in the pneumatic system (AMM 36-00-00/201).
EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú
36-11-01
ALL ú ú 04 Page 432 ú Jun 18/01
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
747-400 MAINTENANCE MANUAL
(2) S 014-190Open the 315AL access door in the area aft of the stabilizer box compartment.
(3) S 214-191Get access to the APU pneumatic duct restraint.
(4) S 434-175Put the duct restraint strap around the duct.
(5) S 434-176Put the duct restraint clamp around the duct.
(6) S 824-177Align the two restraint cables with the duct restraint strap in order to install the bolts.
(7) S 434-178Install both bolts (along with washers, nuts, and radius fillers) between the duct restraint strap and the two restraint cables (do not tighten).
(8) S 434-179Install the T-bolt (do not tighten).
(9) S 434-180Tighten the two nuts and bolts between the duct restraint strap and the restraint cables.
S 824-181
CAUTION: MAKE SURE THAT THE UPPER RESTRAINT CABLE DOES NOT TOUCH THE
_______ DUCT.
(10) Push the duct restraint clamp and strap downward to make sure that the upper cable has approximately 1/2-inch deflection.
S 434-183 CAUTION: WHEN THE T-BOLT IS TIGHTENED, DO NOT FLAT-SPOT OR CRUSH THE
_______ DUCT.
(11)
Tighten the T-bolt to a maximum of 20 inch-pounds. S 824-184
(12)
If installed, adjust the turnbuckle so that both cables have the same tension.
EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú
36-11-01
ALL ú ú 03 Page 433 ú Jun 18/01
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
747-400 MAINTENANCE MANUAL
E. Put the airplane back to its usual condition. S 414-185
(1) Close the 315AL access door.
EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú
36-11-01
ALL ú ú 03 Page 434 ú Jun 18/01
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
747-400 MAINTENANCE MANUAL
PNEUMATIC DUCT - INSPECTION/CHECK
_________________________________
中國航空網 m.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：747-400 AMM 飛機維護手冊 氣動系統 PNEUMATIC SYSTEM(67)
