05-51-14
 ALL  ú ú 01 Page 201 ú Jul 15/90
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A 
737-300/400/500MAINTENANCE MANUAL
 (d)  If the clean-up cannot be done immediately, apply a layer of corrosion inhibiting compound or engine oil.
 NOTE: This will slow the rate at which the mercury goes____ into the airplane structure.
 (e) (f)  Inspection, clean-up, and repair must be done before the next flight.Examine the lower lobe for mercury contamination. 1) Remove the insulation blankets in the area where the mercury has touched the airplane. a) Discard the insulation blankets. 2) Remove the insulation downstream of the area where the mercury touched the airplane.
 NOTE: Remove the insulation to the nearest lateral____
 fluid dams.
 3) Use a 10X hand lense to visually examine the structure. a) Look for any bare metal, scratches, and/or chiped paint. 4) Any areas from step (f) 3) and any joint which might have been touched by mercury must be X-rayed.
 NOTE: Droplets of mercury show on an X-ray negative____ as small white spots. Mercury corrosion and embrittlement show as tree-like forms which
 penatrate the structural component.
 (g)  Examine the main deck for mercury contamination. 1) Examine the floor seals in the area where the mercury has touched the airplane. 2) If the floor seal appears to have been damaged or touched by the mercury, apply a small amount of water to the floor seal.
 (h)  a) Look to see if the water leaks through the floor seal. 3) If the floor seals show signs of damage, remove the floor panels and examine the structure below.Use a 10X hand lense to examine the seat track rails. 1) Look for bare metal, scratches, and/or chiped paint.

 EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú

 05-51-14
 ALL  ú ú 01 Page 202 ú Jul 15/90
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A 737-300/400/500MAINTENANCE MANUAL
 (i)  If the mercury has touched the airplane near a frame or beam
 components, examine the frame and/or beam.
 NOTE:____ A device which can find mercury (mercury sniffer) is
 recomended to find hidden deposits of mercury when the
 area touched by mercury is large in size.  If available,
 x-ray equipment should be used to detect mercury.
 1)  Look for bare metal, scratches, and chiped paint.
 (j)  Any areas from step (h) or (i) and any joint which might have
 been touched by mercury must be X-rayed.
 NOTE:____ Droplets of mercury show on an X-ray negative as
 small white spots.  Mercury corrosion and embrittlement
 show as tree-like forms which penatrate the structural
 component.
 (k)  If any airplane structure shows signs of mercury contamination,
 the necessary structural repair must be done.
 (l)  Cargo restraining equipment must be replaced if damaged by
 mercury.

 S 142-002
 WARNING: MAKE SURE THERE IS VENTILATION WHEN THE MERCURY AREA IS
_______ CLEANED. MERCURY VAPORS CAN BE TOXIC.
 IF HANDS CONTACT MERCURY, KEEP THEM AWAY FROM MOUTH. DO NOT EAT, SMOKE, OR BLOW NOSE WITHOUT WASHING HANDS CAREFULLY WITH SOAP AND HOT WATER. MERCURY IS POISONOUS.
 (2)  Use cardboard troughs, tape, eye dropers, or a vacuum to remove the mercury.
 (a)  Vacuum airplane structure which has been touched by mercury.
 1)  Use a trap-type glass container and a high flow vacuum cleaner to clean small areas.
 NOTE: Vaporized mercury may be left in the
____ commercial vacuum cleaner. Clean the commercial vacuum cleaner after use.
 2)  Use a mercury vacuum cleaner to clean large areas of mercury contamination.
 EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú

 05-51-14
 ALL  ú ú 01 Page 203 ú Jul 15/90
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
　
中國航空網 m.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：737-300 400 500 AMM 飛機維護手冊 TIME LIMITS/MAINTENANCE CHE(26)