(2)
Put a warning notice in position to tell persons not to operate the landing gear doors.
(3)
Put the safety barriers in position.
R 1EFF : 062-099, 106-149, 151-199, 204-299, 1 12-13-27Page 339 1301-399, 401-499, 1Aug 01/05 1 1 1CES 1
Subtask 12-13-27-860-054
B. Aircraft Maintenance Configuration WARNING : MAKE SURE THAT THE TRAVEL RANGES OF THE FLIGHT CONTROLS ARE
_______ CLEAR. MOVEMENT OF FLIGHT CONTROLS CAN CAUSE INJURY TO PERSONS AND/OR DAMAGE.
(1)
Extend the flaps fully (Ref. TASK 27-50-00-866-008).
(2)
Make sure that the LOCKING TOOL - FLAP/SLAT CONTROL LEVER (98D27803000000) is in position on the flap/slat control lever in the cockpit.
(3)
Extend the spoilers 1 thru 5 (Ref. TASK 27-60-00-866-002).
(4)
Make sure that a COLLAR-SAFETY, SPOILER is installed on each spoiler servo-control.
Subtask 12-13-27-865-059
C. Open, safety and tag this(these) circuit breaker(s):
-------------------------------------------------------------------------------PANEL DESIGNATION IDENT. LOCATION -------------------------------------------------------------------------------49VU FLIGHT CONTROLS/FLP/CTL AND MONG/SYS1 6CV B07 121VU FLIGHT CONTROLS/FLP/CTL AND/MONG/SYS2 8CV Q21
Subtask 12-13-27-010-057
D. Get Access R (1) FOR 6205CM, 6255CM
(a)
Open the applicable Main Landing Gear (MLG) door 734, 744 (Ref. TASK 32-12-00-010-001).
(b)
Make sure that the GROUND LOCK SLEEVE (460005835) is installed on the applicable MLG door actuating-cylinder.
(c)
Put an access platform in position in the applicable MLG bay.
R 1EFF : 062-099, 106-149, 151-199, 204-299, 1 12-13-27Page 340 1301-399, 401-499, 1Aug 01/05 1 1 1CES 1
R (2) FOR 6211CM, 6261CM
(a) Put an access platform below the applicable zone 573(673).
R (b) FOR 6211CM - open the access door 573AB.
R (c) FOR 6261CM - open the access door 673AB.
R (3) FOR 6221CM, 6271CM, 6233CM, 6283CM
(a) Put an access platform below the applicable zone 575(675).
R (b) FOR 6221CM - open the access door 575BB.
R (c) FOR 6271CM - open the access door 675BB.
R (d) FOR 6233CM - open the access door 575FB.
R (e) FOR 6283CM - open the access door 675FB.
4. Procedure_________
WARNING : USE SOLVENTS/CLEANING AGENTS, SEALANTS AND OTHER SPECIAL MATERIALS_______ ONLY WITH A GOOD SUPPLY OF AIR. OBEY THE MANUFACTURERS INSTRUCTIONS. PUT ON PROTECTIVE CLOTHING. DO NOT GET THEM IN YOUR MOUTH. DO NOT SMOKE. DO NOT BREATHE THE GAS. THESE MATERIALS ARE POISONOUS, FLAMMABLE AND SKIN IRRITANT. GET MEDICAL HELP IF YOUR SKIN OR EYES BECOME IRRITATED.
CAUTION : DO NOT GET SEMI-FLUID LUBRICANT ON PLASTIC OR RUBBER MATERIALS._______ SEMI-FLUID LUBRICANT CAN CAUSE DAMAGE TO THE SURFACE. REMOVE UNWANTED SEMI-FLUID LUBRICANT WITH A LINT FREE CLOTH.
R 1EFF : 062-099, 106-149, 151-199, 204-299, 1 12-13-27Page 341 1301-399, 401-499, 1Aug 01/05 1 1 1CES 1 CAUTION : BE CAREFUL WHEN YOU DO MAINTENANCE TASKS ON THE WING TRAILING
_______
EDGE:
-
DO NOT CAUSE DAMAGE TO THE ELECTRICAL CABLE RACEWAYS.
-
DO NOT CAUSE DAMAGE TO THE ELECTRICAL CABLE INSTALLATIONS.
-MAKE SURE THAT THE ELECTRICAL CABLES ARE INSTALLED CORRECTLY. INCORRECT INSTALLATION CAN CAUSE DAMAGE.
Subtask 12-13-27-612-061
A. To Fill the Flap Actuators
-
flap actuator No.1 6205CM(6255CM)
-
flap actuator No.2 6211CM(6261CM)
-
flap actuator No.3 6221CM(6271CM)
-
flap actuator No.4 6233CM(6283CM)
R **ON A/C 062-099, 106-149, 151-199, 204-299, 401-499,
(Ref. Fig. 305/TASK 12-13-27-991-005)
**ON A/C 301-399,
(Ref. Fig. 305A/TASK 12-13-27-991-005-A)
R **ON A/C 062-099, 106-149, 151-199, 204-299, 301-399, 401-499,
(Ref. Fig. 306/TASK 12-13-27-991-006)
(1) Fill the flap actuator No.1 6205CM(6255CM) with clean COMMON GREASE (Material No. 04-025) as follows:
(a)
Use a MISCELLANEOUS (Material No. 19-003) made moist with CLEANING AGENTS (Material No. 11-026) to clean the area around the vent plug (1), and the drain plug (2).
(b)
Remove the vent plug (1) from the flap actuator.
(c)
Remove the drain plug (2) from the flap actuator.
NOTE : The drain plug (2) is at the bottom location on the
____
actuator.
R 1EFF : 062-099, 106-149, 151-199, 204-299, 1 12-13-27Page 342 1301-399, 401-499, 1Aug 01/05 1 1 1CES 1 中國航空網 m.k6050.com 航空翻譯 www.aviation.cn 本文鏈接地址：A320飛機維護手冊 AMM SERVICING 1(77)
