07-11-02
 ALL  ú ú 01 Page 209 ú Sep 28/99
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A

757 MAINTENANCE MANUAL
 JACKING AIRPLANE AXLES - MAINTENANCE PRACTICES
______________________________________________
 1.  General_______
 A.  This section gives instructions to lift the airplane at the axles. The airplane has five axle jack points. Two axle jack points are on each main landing gear. One axle jack point is on the nose landing gear. The pads of the axle jack point are part of the landing gear.
 B.  Figure 201 shows the 757-200 Axle Jacking System Specifications.
 C.  You can lift the airplane at the axle jack points at any aircraft weight up to the maximum taxi weight.
 D.  Two flat tires on the same axle can prevent the use of approved axle jacks. If this occurs, you can use axle jacking bars to lift the axle sufficiently to install the axle jack.
 TASK 07-11-03-582-001
 2.  Lift the Airplane on Axle Jacks________________________________
 A.  Equipment
 (1)  Axle Jacking Bar Set, MLG
 B07008-1 (Preferred for all airplanes, required for airplanes with gross weights greater than, or equal to, 251,000 pounds).
 B07003-15 (Preferred for all airplanes, required for airplanes with gross weights greater than, or equal to, 251,000 pounds)
 B07003-1,-13 (Optional for all airplanes except airplanes with gross weights greater than, or equal to, 251,000 pounds)
 (2)  Axle Jacking Bar Set, NLG
 B07004-12 (Preferred)
 B07004-1 (0ptional)

 NOTE: B07004-12 required for airplanes with
____ gross weights greater than, or equal to, 251,000 pounds.
 (3)  Wheel Chocks
 B.  References
 (1)  
AMM 12-15-01/301, Main Gear Shock Strut

 (2)  
AMM 12-15-02/301, Nose Gear Shock Strut

 (3)  
AMM 32-00-20/201, Landing Gear Downlocks

 EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú

 07-11-03
 ALL  ú ú 02 Page 201 ú May 28/00
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
757
MAINTENANCE MANUAL

AXLE JACKING POINTS FOR THE MAIN LANDING GEAR NOSE LANDING GEAR (LEFT SHOWN - RIGHT EQUIVALENT)
POINT JACKING  JACK SPECIFICATIONS 
LOAD (POUNDS) MAXIMUM 4  JACK HEIGHT (INCHES)  FITTING ADAPTER 
ROLL-UNDER  8EXTENDED 

MAIN GEAR AXLE  2 3 1 58,000 51,500 54,400  6.9 5  916.0  NONE
11.0 6 
4.9 7 
NOSE GEAR AXLE  33,200  6.5 5  15.35  NONE
10.3 6 
4.5 7 

MAXIMUM AIRPLANE JACKING WEIGHT: 221,000 POUNDS MAXIMUM AIRPLANE JACKING WEIGHT: 241,000 POUNDS MAXIMUM AIRPLANE JACKING WEIGHT: 251,000 POUNDS INCLUDES A 35 KNOT WIND LOAD WITH FLAT TIRES TIRES CORRECTLY INFLATED WHEELS ON THE RIMS EXTENDED HEIGHT PERMITS A 2-INCH GROUND CLEARANCE
_______CAUTION:  WHEN JACKING ONE AXLE ONLY, DO NOT JACK THE AXLE 
MORE THAN 11 INCHES HIGHER THAN OTHER AXLE.  THIS 
WILL PREVENT DAMAGE TO THE TRUCK POSITIONER ACTUATOR. 
757-200 
Airplane Axle Jacking 
Figure 201 

EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú

 07-11-03
 ALL  ú
 ú  01  Page 202
 ú  May 28/99 

BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A

757 MAINTENANCE MANUAL
 (4)  AMM 32-42-06/401, Antiskid Transducer
 C. Prepare to Lift the Airplane on Axle Jacks
 S 492-002
 (1)  
Make sure that the landing gear downlocks are installed
 (AMM 32-00-20/201).

 S 862-004

 (2)  
　
中國航空網 m.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：757 AMM 飛機維護手冊 LIFTING & SHORING(9)